S8 Quattro Sedan V8-4.2L (AYS) (2002)
Air Door Actuator / Motor: Service and Repair
Left Footwell Flap Motor -V108-/Rear Footwell Vent Motor -V112-
Left footwell flap motor -V108- and rear footwell vent motor -V112-, removing and installing
NOTE: Mark connector for the motor when removing (danger of swapping with connectors of the other actuator motors).
-
Remove driver-side shelf and side trim of center console
-
Remove 2 screws -A- (motor -V108-) or 2 screws -B- (motor -V112-).
-
Remove motor.
-
Before installing the motor, check mounting of the flap (knob -C- must be located between the stops -B-).
-
If the shaft of the motor is located in such an unfavorable position that it is not possible to install motor See Notes regarding installation.
-
After installing, always check DTC memory.
-
Tighten securing screws -A- and -B- only by hand, tightening torque 4 Ncm (0.35 in. lb).