• 3 Series E36 318tds (M41) TOUR Workshop Manual
  • 1 Service Information
  • 2 Repair Instructions
  • 0 Maintenance And General Data
  • 1 RA Danger Of Poisoning If Oil Is Ingested_absorbed Through The Skin
  • 2 RA Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
  • 3 RA Safety Instructions For Handling Oil
  • 4 RA Pre-delivery Check
  • Page 250
  • Page 251
  • Page 252
  • Page 253
  • 5 RA Lifting Vehicle With A Lifting Platform
  • 6 RA Notes On Using Repair Instructions, Technical Data, Tightening Torques
  • 7 RA Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)
  • Page 257
  • 8 RA Symbols Used And Information In Repair Instructions
  • Page 259
  • 9 RA Air Cleaner_ Replacing Air Cleaner Element (shorten Replacement Interval Accordi
  • 10 RA Battery_ Check Display (magic Eye); If Necessary, Recharge Battery
  • 11 RA Battery_ Checking Acid Level, Topping Up With Distilled Water If Necessary
  • 12 RA Body And Underbody_ Checking For Corrosion And Damage
  • 13 RA Body And Underbody_ Checking For Corrosion And Damage - Except Cavities
  • 14 RA Brake And Clutch Hydraulic System_ Checking Fluid Level, Topping Up If Necessary
  • 15 RA Brake Hydraulics_ Checking Fluid Level, Topping Up If Necessary
  • 16 RA Brake Lines And Connections_ Visual Inspection For Leaks, Damage And Correct Pos
  • 17 RA Changing Brake Fluid
  • 18 RA Changing Coolant
  • 19 RA Changing Differential Oil
  • 20 RA Changing Engine Oil And Oil Filter
  • 21 RA Changing Manual Transmission (gear) Oil
  • 22 RA Checking Clutch Drive Plate For Wear
  • 23 RA Checking Clutch Drive Plate For Wear
  • 24 RA Checking Coolant Level In Event Of Topping Up_ Checking Concentration
  • 25 RA Checking Handbrake Lever Travel, Adjusting According To Setting Specifications I
  • 26 RA Checking Horn, Headlight Flashers And Hazard Warning System
  • 27 RA Checking Instrument And Indication Field Lighting
  • 28 RA Checking Instrument And Indication Field Lighting, Heater Blower
  • 29 RA Checking Lighting System
  • 30 RA Checking Roadworthiness
  • 31 RA Checking Steering For Zero Play Steering Tie Rods And Axle Joints, Steering Gear
  • 32 RA Cleaning Brake Shoes And Drums For Service Brake, Checking Wear, Replacing If Ne
  • 33 RA Coolant Hoses_ Visual Inspection For Leaks
  • 34 RA Diagnostic Brief Test
  • 35 RA Draining Water Separator
  • 36 RA Exhaust System_ Checking Condition, Mounting And Inspecting For Leaks
  • 37 RA Fault Memory Interrogation
  • 38 RA Front And (if Necessary) Rear Disk Brake Linings_ Remove And Install, Check Tota
  • 39 RA Front And Rear Brake Linings_ Checking Lining Thickness With Measuring Gauge
  • 40 RA Fuel Cooler_ Checking For External Contamination, Cleaning If Necessary
  • 41 RA Fuel Lines, Fuel Tank And Fuel Hoses_ Visual Inspection For Routing, Condition A
  • 42 RA Heating_air Conditioning_ Replacing Microfilter_carbon Canister (shorten Replace
  • 43 RA Information_warning Labels
  • Page 295
  • Page 296
  • 44 RA Locking Systems_ Checking Status And Function, Oiling Or Greasing If Necessary
  • 45 RA Microencapsulated Screws
  • 46 RA Oil Change In Manual Transmission
  • 47 RA Oil Change In Rear Differential
  • 48 RA Output Shafts_ Checking Gaiters For Leaks
  • 49 RA Parking Brake_ Checking Function, Adjusting_repairing As Prescribed
  • 50 RA Power Steering_ride-height Control_ Visual Inspection For Leaks, Checking Fluid
  • 51 RA Raising BMW Multi-trailer
  • Page 305
  • Page 306
  • 52 RA Replacing Main Fuel Filter (if Quality Of Diesel Fuel Is Poor, Reducing Interval
  • 53 RA Replacing Main Fuel Filter (shortening Change Interval If Necessary In Event Of
  • 54 RA Resetting Service Interval Indicator According To Factory Specifications
  • Page 310
  • 55 RA Seat Belts_ Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
  • 56 RA Steering Components_ Checking For Zero Clearance, Leaks, Damage And Wear
  • Page 313
  • 57 RA Steering Fluid Reservoir_ Checking Fluid Level, Topping Up If Necessary
  • 58 RA Transmission (all Gears)_ Visual Inspection For Leaks
  • 59 RA Tyres_ Checking Inflation Pressure, Correcting If Necessary (incl
  • 60 RA Underbody Incl
  • 61 RA Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid
  • Page 319
  • Page 320
  • 62 RA Windscreen Wash_wipe System_ Checking Washer Fluid Reservoir And Spray Nozzle Ad
  • 63 RA Windscreen Washer System And Intensive Cleaning System_ Checking Fluid Level, To
  • 64 RA BMW Engine Oil Service (M41)
  • Page 324
  • 65 RA Checking_topping Up Oil Level In Rear Differential
  • 66 RA Oil Change In Manual Transmission
  • 67 RA Oil Change In Rear Differential Incl
  • Page 328
  • 68 RA Notes On Handling Wiring Harnesses And Cables
  • 69 RA Positioning Of Multitrailer Hood For Maintenance And Repair Work
  • Page 331
  • 11 Engine (M41)
  • 12 Engine Electrical System (M41)
  • 13 Fuel System (M41)
  • 16 Fuel Supply System (M41)
  • 17 Cooling System (M41)
  • 18 Exhaust System (M41)
  • 21 Clutch
  • 23 Manual Transmission (MECH)
  • 25 Gear Shift Mechanism (MECH)
  • 26 Propeller Shaft
  • 27 Transfer Box
  • 31 Front Axle
  • 32 Steering And Wheel Alignment
  • 33 Rear Axle
  • 34 Brakes
  • 35 Pedals
  • 36 Wheels With Tyres
  • 37 Integrated Suspension Systems
  • 41 Body (TOUR)
  • 51 Body Equipment (TOUR)
  • 52 Seats
  • 54 Slide-tilt Sunroof And Convertible Top (TOUR)
  • 61 General Electrical System
  • 62 Instruments
  • 63 Lights
  • 64 Heating And Air Conditioning
  • 65 Audio, Navigation And Information System
  • 66 Distance Systems, Cruise Control
  • 71 Parts - Accessories (Engine - Chassis)
  • 72 Parts - Accessories (Body)
  • 84 Communication Systems
  • 86 Trailers
  • 99 Paintwork
  • 3 Technical Data
  • 4 Tightening Torques
  • 6 SI Operating Fluids
  • 7 SI Techniques
  • 8 SI Diagnosis Encoding
  • 9 SI Special Tools-appliances
  • 10 Special Tool