Cobalt L4-2.0L SC VIN P (2005)
Housing Assembly HVAC: All Technical Service Bulletins
A/C - Water Leaks Onto Passenger Floor/Blower Motor Inop
Bulletin No.: 05-08-57-002A
Date: April 08, 2005
TECHNICAL
Subject:
Water on Passenger Floor/Blower Motor Inoperative (Install Deflector)
Models:
2005 Chevrolet Cobalt
2005 Pontiac Pursuit (Canada Only)
Supercede:
This bulletin is being revised to include a GM Part Number. Please discard Corporate Bulletin Numbers 05-08-57-002 (Section 08 - Body and
Accessories).
Condition
Some customers may comment that the front passenger floor is wet or the blower motor in inoperative.
Cause
This condition may be caused by water entering the fresh air inlet to the HVAC case.
Correction
1.
Remove the air inlet grille panel.
2.
Remove the piece of foam strip or weatherstrip that may be attached to the top of the right hand air inlet opening.
3.
Clean the sheet metal around the air inlet with a non-oil based cleaner.
4.
Remove the paper backing from the deflector and install it to the air inlet opening with the adhesive side down. Refer to the illustration above.
5.
Reinstall the air inlet grill panel.
