Corvette V8-6.2L SC (2009)
Parts Information
Obtain the flocking tape from Kent Automotive at 1-800-654-6333 or online at www.kent-automotive.com
You can also use felt adhesive strip, or foam which is 2 mm (0.08 in) thick.
Warranty Information
For vehicles repaired under warranty, use the table.
Disclaimer
Technical Service Bulletin # 08-08-64-012
Date: 080814
Interior - Door Speaker Rattle, Buzz, Squeak
TECHNICAL
Bulletin No.: 08-08-64-012
Date: August 14, 2008
Subject:
Driver, Passenger Front Door Speaker Rattle, Buzz, Squeak (Apply Felt Tape to Front Door Trim Retainers)
Models:
2005-2009 Chevrolet Corvette
Condition
Some customers may comment on a rattle, buzz or squeal coming from driver or passenger side. This noise is more noticeable with heavy bass music.
Cause
This condition may be due to contact between the door metal retainers and fiberglass on the door trim upper four retaining clips. The front door has a
sub-woofer speaker which outputs low frequency bass music. This low frequency causes the trim clips to resonate against the fiberglass inner structure,
causing a buzz or rattle.
Correction
Technicians are to add flocking tape, felt tape or foam (2 mm/0.08 in thick) to the trim retainers per the procedure below:
1.
Verify the customer concern by noting what kind of music and at what radio settings the noise is occurring.
2.
Remove the door panel. Refer to Front Side Door Trim Panel Replacement in SI.
