Impala V8-350 5.7L DSL (1985)
Technical Service Bulletin # 85C10
Date: 850501
Campaign - Incorrect Front & Rear Springs
85C10
3C
May, 1985
Subject:
PRODUCT CAMPAIGN 85C10
INCORRECT FRONT AND REAR SPRING
Model and Year:
1985 FULL SIZE CHEVROLET MODELS EQUIPPED WITH SEO 9C1 (POLICE PACKAGE) AND (SPECIAL HANDLING
SUSPENSION) SEO 7B3 AND ASSEMBLED AT WILMINGTON ONLY
TO:
ALL CHEVROLET DEALERS
General Motors has determined that some 1985 Full Size Chevrolet models equipped with SEO 9C1 (Police Package) and (Special
Handling Suspension) SEO 7B3 may have been assembled with standard front and rear springs rather than the heavy duty springs
that were ordered. As a result, accelerated suspension deterioration can occur.
To correct this condition the front and rear springs will be inspected and when required, replaced on all involved vehicles.
Vehicles Involved
Involved are certain 1985 Full Size Chevrolet models equipped with SEO 9C1 (Police Package) and (Special Handling Suspension)
SEO 7B3 within the following parameters:
Plant
From
Through
Wilmington
FY118982
FY124626
Involved vehicles have been identified by Vehicle Identification Number Computer Listings. Computer listings contain the
complete Vehicle Identification Number, owner name and address data, and are furnished to the involved dealers with the campaign
bulletin. Owner name and address data furnished will enable dealers to follow-up with owners involved in this campaign.
These listings may contain owner names and addresses obtained from State Motor Vehicle Registration Records. The use of such
motor vehicle registration data for any other purpose is a violation of law in several states. Accordingly, you are urged to limit the
use of this listing to the follow-up necessary to complete this campaign. Any dealer not receiving a computer listing with the
campaign bulletin was not shipped any involved vehicles.
OWNER NOTIFICATION
Owners will be notified of this campaign on their vehicles by Chevrolet Motor Division (see copy of Owner Letter included with this bulletin).
DEALER CAMPAIGN RESPONSIBILITY
Dealers are to service all vehicles subject to this campaign at no charge to owners, regardless of mileage, age of vehicle, or ownership, from this time
forward.
Whenever a vehicle subject to this campaign is taken into your new or used vehicle inventory, or it is in your dealership for service in the future, you
should take the steps necessary to be sure the campaign correction has been made before reselling or releasing the vehicle.
Owners of vehicles recently sold from your new vehicle inventory are to be contacted by the dealer, and arrangements made to make the required
modification according to instructions contained in this bulletin.
Service Procedure
1.
Raise vehicle on hoist and inspect front and rear springs. Refer to chart below to establish correct spring application.
INCORRECT SPRING
CORRECT SPRING
FRONT
FRONT
ALPHA CODE
PART NUMBER
ALPHA CODE
PART NUMBER
RK
370978
PC
378503
RM
370979
PC
378503
RN
370980
PC
378503
FM
14003385
PA
378501
FN
14003386
PA
378501
REAR
REAR