300 SRT-8 V8-6.1L VIN W (2005)
Sunroof / Moonroof Module: All Technical Service Bulletins
Body - Sunroof Glass Not Flush With Roof/Won't Close
NUMBER: 23-040-06
GROUP: Vehicle Performance
DATE: September 26, 2006
THE StarSCAN(R) FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET.
StarSCAN(R) UPDATE CD 6.05 WAS THE LAST CD TO CONTAIN FLASH FILES.
SUBJECT:
FLASH: Rear Of Sunroof Glass Is Not Flush To Roof/Sunroof Will Not Close
OVERVIEW:
This bulletin involves selectively erasing and reprogramming the Sunroof Module (SUNR) with new software.
MODELS:
2006
(DR)
Ram Truck
2005 - 2006
(LE)
300C/300C Touring
2004 - 2006
(LX)
300/Charger/Magnum
2005 - 2006
(WH)
Grand Cherokee (International Markets)
2005 - 2006
(WK)
Grand Cherokee
2006
(XH)
Commander (International Markets)
2006
(XK)
Commander
NOTE:
This bulletin applies to vehicles equipped with a sunroof (sales code GWA or GWF).
SYMPTOM/CONDITION:
DIAGNOSIS:
1.
Verify the rear of the sunroof glass to roof flushness concern.
2.
UNCALIBRATE THE SUNROOF.
a.
Insure the battery is at least 12 Volts.
b.
Place the ignition switch in RUN position.
c.
Locate the sunroof fuse (Fuse 44 in the Power Distribution Center located in the trunk).
d.
While the sunroof is still in motion, have an assistant remove the sunroof fuse.
e.
Reinstall the sunroof fuse.
3.
RECALIBRATE THE SUNROOF
a.
Press and hold the sunroof vent switch until it stops at the full vent position.
b.
Verify sunroof operation by opening, closing, and venting the sunroof.
c.
If the uncalibrate/recalibrate procedure corrected the sunroof glass to roof fit, perform the Repair Procedure.
4.
If the uncalibrate/recalibrate procedure did not eliminate the sunroof glass to roof fit, use the procedures outlined in TechCONNECT(R)
BODY/SUNROOF/GLASS PANEL/ADJUSTMENTS to adjust the glass panel. If the sunroof glass is now flush, perform the Repair Procedure.