Pacifica V6-3.8L VIN L (2005)
Technical Service Bulletin # F44
Date: 061101
Recall - Fuel Pump Module Replacement/PCM Software
November 2006
Dealer Service Instructions for:
Safety Recall F44
Fuel Pump Module and/or Reprogram PCM
Effective immediately, all repairs on involved vehicles are to be performed
according to this recall. Service Bulletin #18-039-05 is being cancelled.
Models
2005 - 2006 (CS) Chrysler Pacifica
NOTE:
This recall applies only to the above vehicles built from July 8, 2004 through November 24, 2005 (MDH 070800 through 112400).
IMPORTANT:
Many of the vehicles within the above build period have already been inspected or repaired and, therefore, have been excluded from this recall.
IMPORTANT:
Some of the involved vehicles may be in dealer new vehicle inventory. Federal law requires you to complete this recall service on these vehicles
before retail delivery. Dealers should also consider this requirement to apply to used vehicle inventory and should perform this recall on vehicles in
for service. Involved vehicles can be determined by using the VIP inquiry process.
Subject
The fuel pump module and/or the Powertrain Control Module (PCM) software on about 127,900 of the above vehicles may allow the engine to stall if
the vehicle is driven under certain operating conditions. This could cause a crash without warning.
Repair
The PCM must be reprogrammed (flashed) on all involved vehicles. The driver's side fuel pump module must also be replaced on vehicles built from
August 1, 2004 through September 30, 2004 (MDH 080100 through 093023). Refer to the DealerCONNECT VIP function and/or the Global Recall
System (GRS) to determine those VIN's that need a fuel pump and a PCM reprogram vs. those that need a PCM reprogram only.