Daytona IROC V6-181 3.0L SOHC VIN 3 FI (1992)
Fuel Gauge Sender: All Technical Service Bulletins
Fuel Level Sending Unit - Thumping Noise
NO.:
14-05-92
GROUP:
Fuel
DATE:
Jun. 1, 1992
SUBJECT:
"Thumping" Noise From The Rear Of The Vehicle
MODELS:
1992 (AG) Daytona (AP) Sundance/Shadow/Shadow Convertible
SYMPTOM/CONDITION:
Some vehicles built between MDH 022119 and 030608, may experience a "Thumping" noise from the rear of the vehicle (similar to a loose shock
absorber). The noise will usually occur when the fuel gauge reads 3/4 to 7/8, during a light acceleration from a standing start or during braking.
DIAGNOSIS:
If the vehicle exhibits these conditions and the MDH is between 022119 and 030608, proceed with the following repair.
PARTS REQUIRED:
1
Fuel Level Sending Unit Package
4723105
Package Contents:
1
Fuel Level Sending Unit
5217842
1
Seal, Fuel Sending Unit
3404451
REPAIR PROCEDURE:
This repair involves replacement of the fuel level sending unit with a revised one.
Remove the fuel level sending unit from the fuel tank as outlined on page 14-13 of the 1992 Front Wheel Drive Service Manual, Publication
#81-27-2102, and install the revised unit.
POLICY:
Reimbursable within the provisions of the warranty.
TIME ALLOWANCE Labor Operation No. 08-45-30-97 ........................... 0.7 Hrs.
FAILURE CODE:
54 - Improperly assembled