Explorer 2WD V6-245 4.0L SOHC VIN E EFI (1997)
Transmission Speed Sensor: Technical Service Bulletins
A/T - Overdrive Drum Speed Sensor Deleted
Article No.
97-15-28
07/21/97
TRANSMISSION - 5R55E - OVERDRIVE DRUM SPEED
SENSOR DELETED - SERVICE TIP
LIGHT TRUCK:
1997 AEROSTAR, EXPLORER, RANGER
ISSUE:
The Overdrive Drum Speed (ODS) sensor has been deleted as a running change. This may cause the Powertrain Control Module (PCM) to receive stray
signals from the non4unctional ODS sensor that may affect the operation of the transmission.
ACTION:
Disconnect the ODS sensor connector, Cut off the connector end and splice the wires together. This should reduce the possibility of stray signals
affecting the operation of the transmission. Refer to the following Service Procedure for details.
SERVICE PROCEDURE
1.
Disconnect the ODS sensor connector from the sensor.
2.
Cut off the connector end.
3.
Splice and solder the two (2) wires together.
4.
Shrink wrap the wires and secure the wires to the harness. For proper wire splicing techniques, refer to the Augat Connector Repair Kit Manual.
5.
Leave the sensor installed if using the original case. New service cases will not have an ODS sensor hole in the case.
PART NUMBER
PART NAME
F77Z-7005-DD
Transmission case
OTHER APPLICABLE ARTICLES: NONE
WARRANTY STATUS: Eligible Under The Provisions Of Bumper To Bumper WarranW Coverage
OPERATION
DESCRIPTION
TIME
971528A
Eliminate Overdrive Drum
0.3 Hr.
Speed (ODS) Sensor
Connector As Outlined
DEALER CODING
CONDITION
BASIC PART NO.
CODE
7005
12
OASIS CODES: 501000, 502000, 504000