F 150 2WD V8-4.6L (2008)
pulled outboard if the hooks are not properly engaged to the flange. This will confirm the flange has not been bent too far forward. If the rear edge
and split joint stays down and the margin on the inboard edge to the LH part is consistent, then complete installation of the LH cowl has been
achieved. (Figure 3)
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION
DESCRIPTION
TIME
082505A
2004-2008 F-150,
0.3 Hr.
2006-2008 Mark LT:
Attempt To Seat Cowl
Panel, Includes Time To
Adjust Flange If Necessary
(Do Not Use With 17508A
17526A, 17528A)
DEALER CODING
CONDITION
BASIC PART NO.
CODE
7002010
07
Disclaimer
Technical Service Bulletin # 08-25-5
Date: 081222
Body - L/H Cowl Panel Popped Up
TSB 08-25-5
12/22/08
DRIVERS SIDE COWL PANEL POPPED-UP
FORD:
2004-2008 F-150
LINCOLN:
2006-2008 Mark LT
This article supersedes TSB 07-24-5 to update the Service Procedure.
ISSUE
Some 2004-2008 F-150 and 2006-2008 Mark LT (Excluding Heritage) vehicles may encounter a concern of the windshield cowl panel not being fully
seated, popped up or giving the appearance of being warped.
ACTION
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
NOTE
HEAVY-PRESSURE MAY RESULT IN BREAKING OF THE J-HOOK.