F 150 4WD V8-4.6L VIN 8 (2010)
Canister Purge Control Valve: Customer Interest
Emissions - Rough Running/Hard Start/DTC's Set
TSB 11-1-5
01/25/11
RUNS ROUGH, HARD START AFTER REFUELING,
AUDIBLE CLICKING NOISE UNDER HOOD, AND/OR
DTCS P0316, P144A, P1450, PO17X, P044X, P045X,
BUILT ON OR BEFORE 11/1/2010
FORD:
2010-2011 Fusion
2009-2010 F-150
2009-2011 E-Series, Escape, Expedition
2011 F-250, F-350
LINCOLN:
2011 MKZ
2009-2011 Navigator
MERCURY:
2010-2011 Milan
2009-2011 Mariner
ISSUE
Some 2009-2010 F-150, 2009-2011 Expedition, Navigator, E-Series, Escape Hybrid, Mariner Hybrid, 2010-2011 Fusion Hybrid, Milan Hybrid, 2011
MKZ Hybrid and F-Super Duty 250/350 equipped with a 6.2L engine and built on or before 11/1/2010, may exhibit a running rough concern, hard start
after refueling, audible clicking noise under the hood and/or diagnostic trouble codes (DTCs) P0316, P144A, P1450, PO17X, P044X, P045X.
ACTION
Follow the Service Procedure to correct the condition.
SERVICE PROCEDURE
Replace the Evaporative Emission Canister Purge Valve. Refer to Workshop Manual, Section 303-13.
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.