F 350 2WD Super Duty V8-6.4L DSL Turbo (2009)
-
Disconnect: Suspect Ajar Switch .
-
Do the courtesy lamps illuminate?
Yes
INSTALL a new ajar switch in question. TEST the system for normal operation.
No
GO to D2.
-------------------------------------------------
D2 CHECK THE AJAR SWITCH CIRCUIT FOR A SHORT TO GROUND
-
Disconnect: SJB C2280c.
-
Measure the resistance between the suspect ajar switch, harness side and ground as follows:
-
Is the resistance greater than 10,000 ohms?
Yes
GO to D3.
No
REPAIR the circuit in question. TEST the system for normal operation.
-------------------------------------------------
D3 CHECK FOR CORRECT SJB OPERATION
-
Disconnect all the SJB connectors.
-
Check for:
-
corrosion
-
damaged pins
-
pushed-out pins
-
Connect all the SJB connectors and make sure they seat correctly.
-
Operate the system and verify the concern is still present.
-
Is the concern still present?
Yes
INSTALL a new SJB. TEST the system for normal operation.
No
The system is operating correctly at this time. The concern may have been caused by a loose or corroded connector.
-------------------------------------------------
Pinpoint Test E: The Demand Lamps Are Inoperative
Interior Lighting
Pinpoint Tests
Pinpoint Test E: The Demand Lamps Are Inoperative