ford Workshop Repair Guides

Ford Workshop Service and Repair Manuals

ABOUT US
Steering Wheel > < Steering Column

Fiesta 2002.25 (11.2001-)

Steering Column - Steering Column Fiesta 2002.25 (11/2001-)
Removal and Installation

Removal

  1. Remove the driver air-bag module.
    For additional information, refer to: Driver Air Bag Module (501-20B Supplemental Restraint System, Removal and Installation).

  1. Remove the instrument panel lower panel.
    1. Remove the lower retaining screws.
    1. Remove the upper retaining screws from the stowage compartment.
    1. Release the clip.

  1. Detach the audio control switch from the steering column lower shroud (if equipped).
    • Using a thin bladed screwdriver, release the locking tang.

  1. Remove the audio control switch (if equipped).
    • Disconnect the electrical connector.

  1. NOTE:
    NOTE:Turn the steering wheel to gain access to the steering column upper shroud retaining clips.
    Detach the steering column upper shroud from the steering column lower shroud (steering wheel shown removed for clarity).
    1. Using a thin bladed screwdriver, release the two clips, (one each side).
    1. Detach the shroud.

  1. Remove the steering column lower shroud (steering wheel shown removed for clarity).
    1. Remove the retaining screws.
    1. Release the steering column locking lever.

  1. NOTE:
    NOTE:Make sure that the road wheels are in the straight ahead position.
    Centralize the steering and lock it in position.

  1. Detach the steering column shaft from the steering gear pinion.
    • Discard the retaining bolt.

  1. Disconnect the ignition switch and turn signal electrical connectors.
    • Depress the locking tangs.

  1. Disconnect the passive anti-theft system (PATS) transceiver, windshield wiper/washer switch and clockspring electrical connectors.
    • Depress the locking tangs.

  1. Remove the steering column.
    • Discard the retaining nuts.

Installation

  1. WARNING:
    WARNING:Install a new steering column shaft to steering gear pinion retaining bolt. Failure to follow this instruction may result in personal injury.
    WARNING:
    WARNING:Make sure that the steering column locking lever is in the locked position. Failure to follow this instruction may result in personal injury.
    WARNING:
    WARNING:Install new steering column retaining nuts. Failure to follow this instruction may result in personal injury.
    To install, reverse the removal procedure.

Steering Wheel > < Steering Column