Mustang V8-302 5.0L COBRA (1995)
Torque Converter: All Technical Service Bulletins
Torque Converter Clutch - Vibration/Shudder
Article No.
96-25-17
12/02/96
FORD:
1992-95 CROWN VICTORIA
1994-95 MUSTANG, THUNDERBIRD
LINCOLN-MERCURY:
1992-95 GRAND MARQUIS, TOWN CAR
1993-95 MARK VIII
1994-95 COUGAR
ISSUE:
Torque converter clutch shudder or vibration may occur under light to moderate acceleration above 56 km/h (35 mph) while in 3rd or 4th gear or on
3-4/4-3 shifts. This condition may be more noticeable on higher mileage vehicles (24,000+ km (15,000+ mi)) when the torque converter clutch engages
or disengages on light to moderate acceleration.
ACTION:
Perform normal diagnostics and change the transmission fluid. Changing the transmission fluid should reduce the possibility of shudder/vibration. Refer
to the following Service Procedure for details.
SERVICE PROCEDURE
1.
Drain all transmission fluid including the torque converter. Completely drain the cooler and cooler lines. Refer to the appropriate model/year
Service Manual, Section 07-01, for more details.
NOTE:
IF TORQUE CONVERTER SHUDDER OCCURS BELOW 11,250 km (7,000 MILES) OR ABOVE 32,000 km (20,000 MILES), THE CONCERN
IS DUE TO AUTOMATIC TRANSMISSION FLUID CONTAMINATION AND/OR BREAKDOWN. PROCEED TO STEP 7.
NOTE:
IF TORQUE CONVERTER SHUDDER OCCURS BETWEEN 11,250 km (7,000 MILES) AND 32,000 km (20,000 MILES), THE CONVERTER
MAY BE AT FAULT. PROCEED TO STEP 2.
2.
Remove the transmission and replace the torque converter.
3.
Remove the transmission pan and clean the pan and magnet.
4.
Inspect the transmission gasket and filter. Reuse the pan gasket and filter if they are not damaged.
5.
Reinstall the transmission filter, pan gasket and pan.
6.
Reinstall the transmission.
7.
Verify that bulk fluid does not have moisture contamination. If suspected, use quart containers of MERCON(R). Refill transmission with the
proper amount of Motorcraft MERCON(R) Multi-Purpose Automatic Transmission Fluid (ATF) (XT-2-QDX).
NOTE:
REPLACE THE TORQUE CONVERTER IF THE SHUDDER RETURNS IN LESS THAN 16,000 km (10,000) MILES FOLLOWING THE
FLUID CHANGE.
PART NUMBER
PART NAME
F6AZ-7902-ARM
Torque Converter
F6ZZ-7902-ARM
Torque convener
F4LY-7902-ARM
Torque Converter
F4SZ-7902-BRM
Torque Converter
XT-2-QDX
Motorcraft MERCON(R) Multi-Purpose
Automatic Transmission fluid (ATF)
OTHER APPLICABLE ARTICLES: 95-23-4