Taurus X FWD V6-3.5L (2008)
Air Door Actuator / Motor: Customer Interest
A/C - Thump/Flutter Noise From Rear A/C Unit
TSB 08-3-2
02/18/08
THUMP/FLUTTER NOISE FROM AUXILIARY (REAR)
CLIMATE CONTROL SYSTEM - BUILT BEFORE
12/15/2007
FORD:
2008 Taurus X
ISSUE
Some 2008 Taurus X vehicles built before 12/15/2007 may exhibit a thump or flutter noise from the auxiliary (rear) climate control system. This may be
due to movement between the mode door and the climate control housing.
ACTION
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
1.
Remove the auxiliary mode door actuator. Refer to Workshop Manual, Section 412-02.
2.
Install the 0-ring over the mode door shaft until it rests against the mode door housing.
3.
Install the auxiliary mode door actuator.
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION
DESCRIPTION
TIME
080302A
2008 Taurus X: Install
0.9 Hr.
0-Ring Includes Time To
Remove Quarter Trim
Panel And, Auxiliary Mode
Door Actuator (Do Not Use
With 19700D, 19700D7,
31012A)
DEALER CODING
CONDITION
BASIC PART NO.
CODE
18C424
33
Disclaimer
