Cherokee 2WD L6-4.0L VIN S (1998)
13.
In the engine compartment, slide the booster forward, tilt it upwards slightly and then remove it from the engine compartment.
14.
Remove the dash panel seal from the brake booster.
15.
Install the dash panel seal on the new brake booster.
16.
Install the new brake booster into position on the dash panel.
17.
Inside of the vehicle, lubricate the brake pedal pin and bushing with Mopar multi-mileage grease or equivalent.
18.
Loosely install the four (4) brake booster attaching nuts (Figure 4).
19.
Slide the booster push rod over the pedal pin. Secure the push rod with the provided retainer clip (Figure 3).
20.
Tighten the four (4) brake booster attaching nuts to 29 ft-lbs (39 N.m).
21.
Adjust the brake switch by pulling up on the brake pedal as far as it will go. A racheting noise from the brake switch is considered normal.
22.
For Cherokee (XJ) vehicles, install the knee blocker and lower steering column cover.
23.
In the engine compartment, connect the vacuum hose to the brake booster.
24.
Install the master cylinder onto the new brake booster (Figure 2). Tighten the attaching nuts to 155 in-lbs (18 N.m).
25.
Install the combination valve onto the new brake booster (Figure 2). Tighten the attaching nuts to 155 in-lbs (18 N.m).
26.
For Cherokee (XJ) vehicles equipped with ABS, tighten the three (3) ABS HCU bracket fasteners securely.
27.
For Cherokee (XJ) vehicles, install the air filter housing cover.
28.
For Wrangler (TJ) vehicles, install the evaporative canister and bracket assembly.
29.
For Grand Cherokee (ZJ) vehicles, connect the crankcase ventilation system hose to the air filter housing cover.
30.
Connect the negative battery cable.
Completion Reporting and Reimbursement
Claims for vehicles which have been serviced must be submitted on the DIAL System. Claims submitted will be used by Chrysler to record recall service c
Use one of the following labor operation numbers and time allowances:
Labor Operation
Time
Number
Allowance
^
Inspect brake booster date code
05764181
0.2 hours
^
Inspect brake booster date code and replace power brake booster
^
Grand Cherokee (ZJ) and Wrangler (TJ)
05764182
0.4 hours
^
Cherokee (XJ)
05764183
0.7 hours
Add the cost of the recall parts package plus applicable dealer allowance to your claim.
Note:
See the Warranty Administration Manual, Recall Claim Processing Section for complete recall claim processing instructions.
Parts Return and Vehicle Not Available
Parts Return
Not required.
Vehicle Not Available
If a vehicle is not available for service for a known reason, let us know by filling out the pre-addressed Vehicle Disposition Form portion of the Owner
Notification Form or describe the reason on a postcard and mail to: