Cherokee 4WD L6-4.0L VIN S (1998)
Air Door Actuator / Motor: All Technical Service Bulletins
Heater A/C Actuator - Squeaking Noise
NO: 24-03-98
GROUP: Heating & A/C
DATE: Mar. 20, 1998
SUBJECT:
Heater A/C Actuator Squeak
MODELS:
1997 - 1998 (TJ) Wrangler
1997 - 1998 (XJ) Cherokee
SYMPTOM/CONDITION:
A squeaking noise may be present when the system mode is changed from floor to panel or defrost.
DIAGNOSIS:
Operate the system, changing the mode from floor to panel and defrost. If the noise is present, perform the Repair Procedure.
PARTS REQUIRED:
1
06100839
Clip
REPAIR PROCEDURE:
This bulletin involves lubricating the heater floor door actuator lever and installing a retaining clip.
1.
Place the heater a/c system in the panel mode to gain easier access to the floor door actuator. The actuator is located at the left end of the heater
housing, above the transmission tunnel, near the accelerator pedal. Lubricate the actuator lever by brushing a on small amount of white grease
(MOPAR Lubriplate, p/n 04549616).
2.
Install the clip, p/n 06100839, to prevent any excessive movement of the actuator arm. (See Figure 1)
POLICY: Reimbursable within the provisions of the warranty.