Discovery I (LJ) V8-4.0L (1996)
Normal warranty policy and procedures apply
NOTE:
Claims will not be accepted for vehicles outside of the above VIN ranges
COMP. CODE
D456
SRO
Right Front Door
D456 Option 1 - Time 0.65 hrs
Install upper latch screw and inspect all doors
D456 Option 2 - Time 2.40 hrs
Install upper latch screw, inspect all doors and replace door latch
Left Front Door
76.37.89/31 - Time 1.90 hrs
Replace door latch
Rear Side Door
76.37.89/32 - Time 0.80 hr
Replace door latch and straighten door case (each door)
Recall Repair of Right Front Door Latch (All Vehicles In Range)
A.
Recall Inspection and Repair
1.
Verify that Recall D456 repair has not been previously performed by inspection for a recall label on the front cross member.
2.
Remove and discard upper latch retention screw on right front door latch.
3.
Install a new latch screw (STC3763) and washer (AFU1069) in the upper mounting hole (figure 1).
4.
Tighten new screw to 4-5 Nm. (36-45 lbf. in.).
B.
Right Front Door Latch Inspection
1.
Open RH front door and raise the window.
2.
Perform the following inspection using first the exterior door handle and then the interior door handle:
^
Lock and then unlock the door using the sill button. This step places the latch paw in the fully seated position.