Navigator 2WD V8-5.4L (2007)
Front Door Weatherstrip: Customer Interest
Body - Wind Noise From Front Door B-Pillar Area
TSB 07-13-4
07/09/07
WIND NOISE AROUND FRONT DOORS - BUILT
BEFORE 1216/2006
FORD:
2007 Expedition
LINCOLN:
2007 Navigator
This article supersedes TSB 07-8-6 to clarify vehicle build date.
ISSUE
Some 2007 Expedition and Navigator vehicles built before 12/6/2006 may experience wind noise around the exterior driver and/or passenger doors. This
may be most noticeable near the b-pillar area of the door.
ACTION
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
NOTE
IF THE VEHICLE IS BUILT AFTER 12/6/2006, THIS TSB DOES NOT APPLY. PROCEED WITH NORMAL WORKSHOP MANUAL
DIAGNOSTICS, REFER TO WORKSHOP MANUAL (WSM), SECTION 100-04.
1.
Check the build date of the vehicle.
a.
If the build date of the vehicle is before 12/1/2006, continue to Step 2.
b.
If the build date of the vehicle is between 12/1/06 and 12/6/06, continue to Step 3.
2.
Verify that the glass run inserts at the b-pillar corner are still in the correct position. (Figure 1)
a.
First roll down the window and peel back the inner flocked sealing lip in the b-pillar corner.
b.
There will be two inserts located in the corner. They should both be touching in the corner and at a 90 degree angle.
