Mariner 2WD L4-2.5L (2009)
Torque Converter: All Technical Service Bulletins
A/T - Torque Converter Knocking Noises
TSB 09-10-3
06/01/09
6F35 AUTOMATIC TRANSMISSION TORQUE CONVERTER
KNOCK - BUILT BEFORE 8/29/2008
FORD:
2009 Escape
MERCURY:
2009 Mariner
ISSUE
Some 2009 Escape and Mariner vehicles equipped with a 6F35 automatic transmission and built before 8/29/2008 may exhibit a continuous knocking
noise heard with the engine running and vehicle stationary or moving slow. The noise is heard in drive and/or reverse, and is not typically heard in
neutral and/or park. This noise may be due to the torque converter assembly.
ACTION
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
NOTE
IF THE VEHICLE HAS A 3.0L V6, AUTOMATIC TRANSMISSION, AND THE NOISE IS HEARD IN ALL 4 POSITIONS (P,R,N,D), THEN
THIS PROCEDURE DOES NOT APPLY.
1. Verify vehicle was built before 8/29/2008 and the noise is continuous knocking noise, heard from rear of engine and/or front of transmission, with
engine running and vehicle stationary or moving slow.
a. Is the noise present in (D) and/or (R) but not in (N) and/or (P)? If yes, then go to Step 2.
b. Is the noise is heard in all four positions (P,R,N,D)? If yes, then stop. This procedure does not apply and refer to Workshop Manual (WSM),
Section 303-00.
2. Use chassis ears to listen for noise at the bottom of the transmission near the torque converter access hole. If noise is present, then replace the torque
converter per WSM, Section 307-O1A
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION
DESCRIPTION
TIME
091003A
2009 Escape, Mariner 2.5L
4.6 Hrs.
4X2: Replace The Torque
Converter Includes Time
To Verify Noise (Do Not
Use With Any Other Labor
Operations)
091003A
2009 Escape, Mariner 2.5L
5.2 Hrs.
4X4: Replace The Torque
Converter Includes Time
To Verify Noise (Do Not
Use With Any Other Labor