Mariner 2WD V6-3.0L (2008)
Starter Motor: Customer Interest
Engine - Grinding Rattling Noises
TSB 07-14-9
07/23/07
ENGINE NOISE - GRINDING/RATTLE MOST
NOTICEABLE AT IDLE - VEHICLES BUILT FROM
4/27/2007-4/30/2007.
FORD:
2008 Escape
MERCURY:
2008 Mariner
ISSUE
Some 2008 Escape and Mariner vehicles equipped with a 3.0L engine, may exhibit a grinding or rattling noise with the engine running, more noticeable
at idle.
ACTION
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
1.
Check the vehicle build date:
a.
If the vehicle was built from 4/27/2007-4/30/2007, go to Step 2.
b.
If not, follow normal diagnostics using Workshop Manual (WSM), Section 100-04.
2.
Remove the starter, Refer to WSM, Section 303-06.
a.
Inspect the starter drive for loose washers and/or the snap ring not seated in the shafi groove. Replace as necessary.
3.
Install the starter, Refer to WSM, Section 303-06.
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage IMPORTANT: Warranty coverage limits/policies are
not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION
DESCRIPTION
TIME
071409A
2008 Escape/Mariner 3.0L
0.6 Hr.
Engine: Replace Starter,
Includes Time To Inspect
Build Date And Starter
Drive (Do Not Use With
11002A)
Disclaimer