Milan FWD V6-3.0L (2010)
NOTE: Always make sure the correct Supplemental Restraint System (SRS) component is being installed. Parts released for other vehicles may not be
compatible even if they appear physically similar. Check the part number listed in the Master Parts Catalog to make sure the correct component is being
installed. If an incorrect SRS component is installed, DTCs may set.
NOTE: The air bag warning indicator illuminates when the correct Restraints Control Module (RCM) fuse is removed and the ignition is ON.
NOTE: The SRS must be fully operational and free of faults before releasing the vehicle to the customer.
1. Depower the SRS. For additional information, refer to Supplemental Restraint System (SRS) Depowering and Repowering See: Air Bag(s)
Arming and Disarming/Service and Repair/Supplemental Restraint System (SRS) Depowering and Repowering in the General Procedures portion.
2. Remove the 2 screws and steering column opening trim panel.
3. Remove the three screws and lower steering column shroud.
4. Remove the 4 bolts and steering column opening cover reinforcement.
5. Disconnect the knee air bag module electrical connector.
6. Remove the wiring harness from the knee air bag module bracket.
7. From the back side of the instrument panel bracket, remove the 4 knee air bag module bolts.
8. Remove the knee air bag module.
9. Remove and discard the 4 J-nuts.
Installation
1. Install 4 new J-nuts.
2. Install the knee air bag module and 4 bolts.
-
Tighten to 9 Nm (80 lb-in).
3. Connect the knee air bag module electrical connector.
4. Attach the wiring harness to the knee air bag module bracket.
5. Install the lower steering column shroud.
6. Install the steering column opening cover reinforcement and 4 bolts.
-
Tighten to 3 Nm (27 lb-in).
7. Install the steering column opening trim panel and 2 screws.
8. Repower the SRS. For additional information, refer to Supplemental Restraint System (SRS) Depowering and Repowering See: Air Bag(s)
Arming and Disarming/Service and Repair/Supplemental Restraint System (SRS) Depowering and Repowering in the General Procedures portion.
