Aurora V6-214 3.5L VIN H SFI (2001)
Air Duct: All Technical Service Bulletins
A/C - Noise/Inadequate Air Flow
File In Section: 01 - HVAC
Bulletin No.: 00-01-39-002
Date: September, 2000
TECHNICAL
Subject:
Noise in HVAC System/Insufficient Air Flow From HVAC System/HVAC System Pulling/Lifting Papers/Debris From Glovebox Bin (Install Barrier
Material)
Models:
2001 Oldsmobile Aurora
Built Prior to VIN Breakpoint 14123892
Condition
Some customers may comment on the following conditions when the HVAC system is in the RECIRC mode:
^
Noise in the HVAC system near the IP storage compartment (glovebox).
^
Insufficient air flow from the HVAC system or the HVAC does not operate properly.
^
Papers/debris are being pulled/lifted/drawn from the IP storage compartment (glovebox) bin.
Cause
The HVAC module, when in the RECIRC mode, may have sufficient strength to pull/lift/draw papers/debris out of the top of the IP storage compartment
(glovebox) bin when the glovebox door is closed.
The ingestion of the papers/debris may cause noise, insufficient air flow and/or the HVAC module to be inoperative.
Correction
Install a 20.3 cm x 25.4 cm (8 in x 10 in) sheet of barrier material, Adhesive Flocking Tape, P/N 12378189 (P/N 10953434 in Canada), between the IP
storage compartment (glovebox) bin and the air duct in order to close off the glovebox bin opening.
Repair Procedure
1.
Fold the 20.3 cm x 25.4 cm (8 in x 10 in) sheet of Adhesive Flocking Tape, P/N 12378189 (P/N 10953434 in Canada), lengthwise into three
sections with the paper backing (1) to the outside.