Cutlass Supreme V6-3100 3.1L MFI VIN M (1994)
Suspension Spring ( Coil / Leaf ): All Technical Service Bulletins
Suspension (Rear) - Grinding/Scraping/Groaning Noises
File In Section: 03 - Suspension
Bulletin No.: 99-03-09-004
Date: October, 1999
TECHNICAL
Subject:
Grinding/Scraping/Groaning Noise From Rear Suspension
(Replace Spring Tip Pad)
Models:
1988-96 Buick Regal
1990-94 Chevrolet Lumina
1988-97 Oldsmobile Cutlass Supreme
1988-96 Pontiac Grand Prix
Condition
Some customers may comment on a grinding/scraping/groaning type noise coming from the rear suspension area that is audible in the passenger
compartment. This condition typically occurs on high mileage vehicles that have been operated in areas exhibiting high levels of grit or sand
contamination. The noise is most apparent when the vehicle is operated over irregular road surfaces or during quick starting or braking maneuvers.
Cause
The wearing away or complete/partial detachment of the rubber tip pads on the rear transverse composite leaf spring may result in the unprotected spring
end sliding on the cast knuckle surface.
Correction
Replace worn or missing rear spring rubber tip pads with those contained in spring tip service kit, P/N 10432057, using adhesive, P/N 10432060. Follow
the applicable service procedure in the Rear Suspension sub-section of the Service Manual and those contained in the service kit.
Notice:
If the bare ends of the spring (tip pads removed) exhibit significant wear or gouging greater than 3 mm (1/8 in) in depth. then the spring is damaged
beyond repair and replacement is required.
Parts Information
Part Number
Description
10432057
Insulator Kit
10432060
Adhesive
Parts are currently available from GMSPO.
Warranty Information
For vehicles repaired under warranty, use:
Labor
Labor
Operation
Description
Time
E5300
Spring, Rear Transverse
0.7 hr
Leaf Spring - R&R or Replace
Add:
For Dual Exhaust
0.5 hr
Add:
For Replacing Rubber Tips Not
0.3 hr
Transverse Spring