Neon L4-2.0L SOHC (1995)
Carpet: All Technical Service Bulletins
Carpet Pile - Separates From Backing
NO: 23-41-95
GROUP: Body
EFFECTIVE DATE: Jul. 14, 1995
SUBJECT:
Carpet Pile
Separates
From Backing
MODELS:
1995 (PL) Neon
NOTE:
THIS BULLETIN APPLIES TO VEHICLES BUILT FROM APR. 18, 1995 (MDH 04-18-XX) THROUGH JUN. 8, 1995 (MDH 06-08-XX).
SYMPTOM/CONDITION:
The carpet pile separates from the backing material in patches leaving bare spots. This occurs primarily in the driver or passenger floor area.
DIAGNOSIS:
Using your fingers, pull on the pile in a formed area or an area of the carpet with a vertical surface. If the carpet pile pulls out easily in little tufts
(without the use of pliers or other gripping tool) proceed with the following repair.
PARTS REQUIRED:
AR
PK54RS6
Carpet-4 Door (Quartz) w/Cable Operated Deck Lid Release
AR
PQ56RS6
Carpet-4 Door (Quartz) w/o Cable Operated Deck Lid Release
AR
PK54RF7
Carpet-4 Door (Driftwood) w/Cable Operated Deck Lid Release
AR
PQ56RF7
Carpet-4 Door (Driftwood) w/o Cable Operated Deck Lid Release
AR
PK55RS6
Carpet-2 Door (Quartz) w/Cable Operated Deck Lid Release
AR
PQ16RS6
Carpet-2 Door (Quartz) w/o Cable Operated Deck Lid Release
AR
PK55RF7
Carpet-2 Door (Driftwood) w/Cable Operated Deck Lid Release
AR
PQ16RF7
Carpet-2 Door (Driftwood) w/o Cable Operated Deck Lid Release
REPAIR PROCEDURE:
This bulletin involves replacing the carpet with a revised part.
1.
Remove the front seats, rear seat cushion, front and rear seat belt lower anchor bolts, deck lid remote release mechanism (if so equipped), cowl
trim covers, front and rear door sill trim covers, and center floor console as outlined in the 1995 Neon Service Manual (Publication No.
81-270-5025), Pgs. 23-20 through 23-25.
NOTE:
DO NOT LIFT THE INSTRUMENT PANEL TO REMOVE OR INSTALL THE CARPET AS THIS MAY RESULT IN DAMAGE TO THE
HEATER/AIR CONDITIONING UNIT AND INSTRUMENTATION AND MAY CAUSE UNNECESSARY BUZZ, SQUEAKS OR RATTLES.
