Neon L4-2.0L SOHC (1995)
Air Duct: All Technical Service Bulletins
Defroster - Poor Overall Performance
NO: 24-04-95
GROUP: Heating & A/C
DATE: Feb. 10, 1995
SUBJECT:
Defroster Operation/Improvement
MODELS:
1995 (PL) Neon
SYMPTOM/CONDITION:
Customer complaint of poor defrosting on the driver's side or poor overall defroster performance.
DIAGNOSIS/DISCUSSION:
Verify with the customer the operation of the circulation control knob position when in the defrost mode. As stated in the Owners Manual, the circulation
control must not be in the "RECIRCULATE" mode position in humid/cold weather or the windows may fog or moisture will build up inside the vehicle.
For maximum defogging, use the "OUTSIDE AIR" position on the circulation control.
If the heater-A/C system is being used correctly, proceed to the following repair procedure.
PARTS REQUIRED:
AR
5264604
Lower Defroster Duct Seal (for vehicles built prior to
Feb. 1, 1994 (MDH 02-01-XX).
REPAIR PROCEDURE:
This bulletin involves removing the instrument panel top cover and verifying and/or repairing the upper and lower defroster duct assembly.
1.
Remove the instrument panel top cover by lifting up on the bottom outer areas of the cluster bezel and along the rearward edge of the top cover to
disengage the clips. Pull the top cover and cluster bezel rearward until the forward pins disengage from the instrument panel.
