G6 V6-3.6L (2007)
Sun Shade: Customer Interest
Body - Erratic Sunroof Sun Shade Operation
TECHNICAL
Bulletin No.: 09-08-67-003
Date: January 28, 2009
Subject:
Sunshade Will Roll Out When Panoramic Sunroof Is Closed, But Will Not Rewind When Opening Sunroof (Add Washer, Reinstall Sunshade)
Models:
2005-2007 Pontiac G6
2007 Saturn AURA
Condition
Some customers may comment that upon activation of the sunroof sunshade switch, the sunshade will roll out when the sunroof is closed; however, it
will not rewind while opening the sunroof.
Cause
While remaining connected to the sunroof module, the sunshade assembly may experience enough cross-car movement to disengage the sunshade's
spring tension.
Correction
Install a 2 mm thick, non-metallic washer in order to reduce the cross-car travel of the sunshade assembly.
Important:
The addition of the washer MUST be done on the left side of the sunshade assembly. If done on the right side, the washer will block an access
hole sometimes needed to lock the spring tension of the sunshade.
1.
Cycle the sunshade until the front crossmember is positioned in the opening in the headliner.
2.
Lower the headliner. Refer to Headlining Trim Panel Replacement in SI.