ION L4-2.2L VIN F (2004)
Sunroof / Moonroof Frame: All Technical Service Bulletins
Sunroof - Itch/Squeak Noise
File in Section: 08 - Body and Accessories
Bulletin No.: 04-08-67-004
Issue Date: June, 2004
Subject:
Itch/Squeak Type Noise Coming From The Sunroof Area
(Trim Sunroof Reinforcement Flange Tabs)
Models Affected:
2004 ION Coupe with sunroof (RPO CF5)
Attention: Technician
Condition:
Under normal driving conditions, the customer may comment about an itch/squeak type noise coming from the sunroof area.
Cause:
The sunroof reinforcement flange is mounted too low with regard to the roof flange and the tabs of the sunroof reinforcement flange may make contact
with the sunroof module causing an itch/squeak type noise.
Correction:
Trim the sunroof reinforcement flange tabs flush with the roof flange.
Inspection Procedure:
1.
To inspect for the sunroof reinforcement flange tab to sunroof module interference, open the sunshade and sunroof glass all the way.
2.
Locate the outboard side roof flanges and the sunroof reinforcement flange tabs from outside of the vehicle.
3.
If the sunroof reinforcement flange tabs protrude below the roof flange, they will need to be trimmed off following the procedure outlined in this
bulletin.
4.
If sunroof reinforcement flange tabs do not protrude below the roof flange, do not proceed with this bulletin. Further diagnostics for the customer
concern is required.
Repair Procedure:
Sunroof Removal Procedure
