ION L4-2.2L VIN F (2004)
Transmission Mount: All Technical Service Bulletins
Transaxle - Front End Vibration/Growl on L/H Turns
Bulletin No.: 04-07-30-009
Date: March 03, 2004
TECHNICAL
Subject:
Vibration and/or Grind/Growl Noise from Front End of Vehicle During Left Hand Turns (Adjust Rear Transaxle Mount)
Models:
2003-2004 Saturn ION Vehicles
Attention:
Technician
Condition
Some customers may comment on a vibration and/or a grind/growl noise from the front of the vehicle on left hand turns.
Cause
The rear transaxle mount may be turned out of position and contacting the rear transaxle mount bracket.
Correction
Using the procedure in this bulletin, adjust the rear transaxle mount.
Procedure
1.
Verify concern using Chassis Ears Tool SA9217NE, or equivalent.
2.
Raise and support the vehicle. Refer to "Lifting and Jacking the Vehicle" in the General Information section of the appropriate Saturn ION Service
Manual.
3.
Inspect rear transaxle mount position in rear transaxle mount bracket.
4.
If rear transaxle mount is not centered in the rear transaxle mount bracket, the rear transaxle mount must be adjusted. Proceed to # 6.
5.
If transaxle mount is properly positioned, use Chassis Ears Tool SA9217NE, or equivalent, to pinpoint the source of the concern.
6.
If the transaxle mount is not properly positioned, loosen the rear transaxle mount to frame bolts but do not remove them.