SW1 L4-1.9L SOHC VIN 8 (1996)
Sun Shade: All Technical Service Bulletins
Sunroof - Sunshade Material Separates From Sunroof
BULLETIN NO.: 98-T-47A
ISSUE DATE: January, 1999
GROUP/SEQ. NO.: Body - 13
CORPORATION NO.: 99-08-110-002
SUBJECT:
Sunroof Sunshade Fabric Material Separates From Sunroof Sunshade at Front and Rear Edges (Re-attach Sunroof Sunshade Fabric)
Due to changes in the subject line, this bulletin is being revised and supercedes bulletin 98-T-47, which should be discarded.
MODELS AFFECTED:
1996-1999 Saturn Sedans and 1997-1999 Saturn Coupes equipped with factory installed sunroof (CF5 option)
CONDITION:
Under normal operating conditions, sunroof sunshade fabric begins to separate from sunroof sunshade.
CAUSE:
Improper adhesion between sunroof sunshade fabric and sunroof sunshade.
CORRECTION:
Re-attach fabric using the following procedure.
PROCEDURE:
1.
Remove sunroof sunshade from vehicle. Refer to "Sunroof Sunshade" in the Body/Repair Service Manual.
2.
Place sunroof sunshade on a clean bench.
3.
Remove old adhesive using a razor blade.
4.
Cover areas that should not have adhesive applied to them.
5.
Apply 3M(R) General Trim Adhesive (P/N 8088), or equivalent, to attaching side of fabric and attaching side of sunroof sunshade. Follow
manufacturer's instructions for drying and application.
6.
Install sunroof sunshade in vehicle. Refer to "Sunroof Sunshade" in the Body/Repair Service Manual.
PARTS REQUIREMENTS:
8088
3M(R) General Trim Adhesive
CLAIM INFORMATION:
To receive credit for this repair during the warranty coverage period, submit a claim through the Saturn Dealer System as shown.