SW1 L4-1.9L SOHC VIN 8 (1996)
Window Track: All Technical Service Bulletins
Body - Rear Side Door Glass Inoperative/Falls Down
BULLETIN NO.: 03-T-05
ISSUE DATE: February, 2003
CATEGORY TYPE: Body/Electrical-02
CATEGORY: Doors/Windows/Mirrors
CORPORATION NO.: 03-08-64-004
SUBJECT:
Rear Side Door Glass Will Not Go Up or Down, or Will Fall Down Unintentionally (Replace Window Glass Sash Bar Slider)
MODELS AFFECTED:
1996-2002 Saturn S-Series Sedans and Wagons
CONDITION:
Some customers may comment that when cycling the rear side door glass, the glass will not move or the glass will not stay in the fill up (closed) position.
CAUSE:
The plastic window regulator slider inside the rear side door glass sash bar, that connects the sash bar to the rear side door window regulator lift arm,
cracks and splits open.
CORRECTION:
Follow the service procedure in this bulletin to replace the window regulator slider (P/N 21172105).
SERVICE PROCEDURE:
1.
Verify condition by removing the rear door trim panel at the affected door. (Refer to the "Rear Door Trim Panel - Sedan/Wagon" Removal
Procedure in the "Doors" section located in the appropriate model year S-Series Body/Repair Service Manual.)
2.
Partially remove the water liner and observe the window regulator slider while cycling the window to verify that it is broken. If broken, continue
with the remaining procedures in this bulletin. If not, continue to examine other components to verify customer complaint.
3.
Remove rear door window regulator. (Refer to the t1Rear Door Window Regulator/Motor - Sedan/Wagon" Removal Procedure in the "Doors"
section located in the appropriate model year S-Series Body/Repair Service Manual.)
