tC L4-2.4L (2AZ-FE) (2005)
Sunroof / Moonroof Frame: All Technical Service Bulletins
Body - Moonroof Creak/Snap Noise On Rough Roads
NVH
NV010-04
REVISED
October 8, 2004
Title:
MOON ROOF (SLIDING ROOF) CREAK
Models:
'05 Scion tC
TSB REVISION NOTICE:
October 12, 2004: Figure 3 has been updated (screw No. 2 is not a Torx screw).
The previous TSB should be discarded.
Introduction
The moon roof assembly on certain 2005 model year Scion tC vehicles may exhibit a creak or snap noise during body flex conditions, such as entering a
driveway or driving on rough roads. The following repair procedure has been developed to improve this condition.
Applicable Vehicles
^
2005 model year Scion tC vehicles produced BEFORE the Production Change Effective VIN shown below.
Production Change Information
Warranty Information
Applicable Warranty:
This repair is covered under the Toyota Comprehensive Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from
the vehicle's in-service date.
* Warranty application is limited to correction of a problem based upon a customer's specific complaint.
Repair Procedure
1.
Open the sliding roof glass.