WARNING | When doing any repair work, especially in the engine compartment, pay attention to the following due to the cramped conditions: |
| t
| Route all the various lines and electrical wiring so that they are in their original positions. |
| t
| e.g. for fuel, hydraulics, activated charcoal filter system, coolant and refrigerant, brake fluid, vacuum. |
| t
| Ensure that there is sufficient clearance to all moving or hot components. |
|
| If in the test drives it is necessary to use the tester units, take note of the following: |
| l
| Test and measuring instruments must always be secured to rear seat and operated by a second person from this location. |
| To avoid injury to personnel and/or damage to the preheating and injection system, the following points should be observed: |
| l
| Persons wearing a pacemaker should not lean over the engine compartment while the engine is running, as the injectors use high voltage pulses. |
| l
| The ignition must be switched off before connecting or disconnecting injection or pre-heating system wiring or tester cables. |
| l
| Always switch off the ignition before connecting or disconnecting the battery, otherwise the diesel direct injection system control unit may be damaged. |
|
|
|
