Impreza 2.5 RS Sedan AWD F4-2.5L SOHC (2002)
Speaker: All Technical Service Bulletins
Audio System - Vibration from Front Door Speakers
NUMBER: 15-119-06
DATE: 11/29/06
APPLICABILITY:
2002MY and Later Impreza
SUBJECT:
Chattering/Vibration from Front Door Speakers
INTRODUCTION
If you encounter a customer complaint that the front door speaker(s) chatter and/or vibrate when the volume is set high, refer to the following repair
procedure.
PARTS/MATERIAL INFORMATION
Countermeasure 1
3M(TM) Heavy Drip-Chek(TM) Sealer 08531
Countermeasure 2
S0A part # 61244FE100, Sealing Cover (with urethane) F Door; RH
SOA part # 61244FE110, Sealing Cover (with urethane) F Door, LH
3M(TM) Windo-Weld(TM) Round Ribbon Sealer 08625 or butyl tape as an equivalent.
Caution:
Make sure to read and follow the directions, precautions. warnings, etc of the 3M(TM) products.
REPAIR PROCEDURE/INFORMATION
Verify the customer's complaint by playing a commercially purchased CD and/or the radio. Note: It is not advisable to play a burned (home made) CD,
due to the fact the recording levels may have been set extremely high, which may cause undesirable chattering, vibration and/or distortion.
1)
Check to make sure there is nothing in the door pockets that could cause chattering and/or vibrations. If there is, remove the objects.
2)
Remove the door trim (refer to the applicable service manual) and check for loose or missing screws, broken or missing clips. Replace if
necessary.
3)
Check to make sure that the sealing cover is properly applied (no peeling, no misalignment, no breakage). Repair and/or replace as necessary.
