Field Remedy: 2078
Subject: |
Engine Z13DTH, ECU - Trouble code U2105
set, crank no start |
Models: |
Engines: |
Option: |
Astra-H 2005...,Corsa-D 2007... |
Z13DTH,Z13DTH| Z13DTJ |
|
Complaint: |
Customer complaints about crank no start
symptom. Whilst carrying out diagnosis TECH 2 has no communication
with ECU. Other systems, i.e. ABS as well as CIM are assessable
with TECH 2 and these systems will definitely show trouble code
U2105 (no communication with ECU). |
Cause: |
Poor electrical connection either at engine
harness or at body/vehicle harness side. |
Production: |
|
Remedy:
In case of customer complaint please note:
Lot’s of ECU´s have been replaced recently because of troubl code:
U2105. All ECU´s were passed to supplier and were tested NTF.
Several vehicles were checked with the following result:
Trouble code U2105 was caused by a voltage drop to the ECU because
of some poor electrical connection either at Engine harness or at
Body/Vehicle harness side. Please perform the following action in
case of complaint:
Astra-H, Z13DTH, [2006-2007], MT, w/o DPF, old HW (55198924),
with Pressure Regulator --->
>
>
SPS-Programing since DVD 82,
SW: 55202542.3
Astra-H, Z13DTH [2007-2009], MT, with DPF, w/o Pressure Regulator
--->
>
>
TIS2Web since 16-Mar-2009 or Global TIS, version 14
(ECU-HW: 55566403 together with ECU-SW: 55573951.3)
Astra-H, Z13DTH [2007-2009], MT, w/o DPF, w/o Pressure Regulator,
Other --->
>
>
TIS2Web since 16-Mar-2009 or Global TIS, version 14
(ECU-HW: 55566403 together with ECU-SW: 55573956.4)
Astra-H, Y13DTH [2007-2009], MTA, w/o DPF, with and w/o Pressure
Regulator --->
>
>
New Service ECU: 55572740 together with
ECU-SW: 55198925 (w/o Pressure Regulator), 55566040
(with Pressure Regulator).
Astra-H, Z13DTH [2007-2009], MT, w/o DPF, with Pressure Regulator
--->
>
>
New Service ECU: 55572740 together with ECU-SW: 55565450.
Astra-H, Z13DTH [2007-2009], MTA, with DPF, with and w/o
Pressure Regulator --->
>
>
New Service ECU: 55572740 together
with ECU-SW: 55566041 (w/o Pressure Regulator), 55198926
(with Pressure Regulator).
Astra-H, Z13DTH [2007-2009], MT, with DPF, with Pressure Regulator
--->
>
>
New Service ECU: 55572740 together with ECU-SW: 55565449.
Corsa-D, Z13DTJ: Vehicles with manual transmission, with pressure
regulator, with/without diesel particulate filter
-->
SPS reprogramming as of TIS 2000-DVD, version 88.
Corsa-D, Z13DTH: Only vehicles without pressure regulator at rail,
with manuel transmission/MTA as well as with/without diesel
particulate filter -->
SPS reprogramming as of TIS 2000-DVD,
version 88.
Electrical analysis of the ECM power supply at the Front Zone
Module:
Fuse: FE21, 20 A, Pin 5, ECU: Must have around 12.5 Volt with
ignition Key turned on.
Fuse: FE30, 10 A, Pin 23, ECU: Around 12.5 Volt with Key-On, 0 Volt
with Key-Off.
Fuse: FE22, 10 A, Pin 50, ECU: Around 12.5 Volt (fixed
supply).
If there is no power supply recognized (neither to the FZM nor
to the ECU) please disassembly and reassemble central plug
from FZM. If the engine does not start problem still exist
please disassemble and reassemble both central plugs from ECU.
Now the engine should start. Concerning assembly of electrical
plugs, etc. please refer to TIS.
FunctionalGroup: |
J - Engine |
Complaint Group: |
06 - Failure Code Setting by Control
Unit |
Trouble Code: |
U2105 |
|