CC (357) V6-3.6L (BLV) (2009)
Sound Proofing / Insulation: Service and Repair
Roof Insulation and Reinforcements, Passat CC
NOTE: An exemplary sedan without sunroof is shown in the following description.
Removing
Sedan
CAUTION: Observe safety precautions for working on airbags.
-
Disconnect vehicle battery
-
Remove the front and rear interior and reading lamps in the headliner
-
Remove storage compartment with console in headliner
-
Remove upper trim on A-pillars
-
Remove sun visors.
-
Basic
-
Double
-
Remove roof grab handle
-
Remove upper B-pillar trim
-
Remove trim on C-pillars, sedan:
-
without sun shade
-
with sun shade
-
Remove roof end strip, sedan
Vehicles in which an interior rearview mirror with rain sensor is installed:
-
Remove the side cover caps from the interior rearview mirror
-
Remove headliner, sedan
Passat CC
-
If equipped, open the Panorama sunroof.
-
Switch off ignition.
-
Remove the front interior and reading lights:
-
Remove the roof grab handles on vehicles without Panorama sunroof
-
Remove upper trim on A-pillars
-
Remove the upper B-pillar trim from the brackets
-
Remove visors.
-
Remove the C-pillar trim:
-
Vehicles not equipped with a sun shade
-
Vehicles equipped with a sun shade
-
Lower the headliner, Passat CC
-
Cut roof insulation/reinforcements - 1 - in direction of travel in strips approx. 6 cm wide - 2 - using a carpet knife.
-
Pull off strips - 2 - from roof.
-
Cut back adhesive residue - 3 - using electric cutter V.A.G 1561 A and cutting blade V.A.G 1561/20 - 4 -.
NOTE: If paint structure was damaged while removing roof insulation/reinforcements, paint damage must be repaired.