GTI V6-2.8L (BDF) (2002)
Sunroof / Moonroof Panel: Adjustments
Sunroof Glass Panel, Adjusting Height (Webasto)
Sunroof Glass Panel, Adjusting Height
Sunroof "0" position OK.
-
Tilt sunroof open.
-
Slide sliding headliner to rear.
-
Unclip lower trim -1- in rear area (arrow), slide forward and remove from roof frame.
-
Unclip front and center of upper trim -2- and unhook at rear.
-
Remove screws -3- (Torx insert T 25).
Tightening torque: 4.5 Nm (40 in. lb).
-
Run glass panel into "closed" position, then open and close again. (The correct order is important for the correct adjustment)
-
Adjust height of glass panel at front and rear on both sides as follows:
Panel adjustment front:
a
=
0 - 1 mm lower than roof
Arrow =
Direction of travel (forward)