New Beetle L5-2.5L (BPS) (2006)
Control Module: Service and Repair
Transmission Control Module (TCM) J217, Replacing
Transmission Control Module (TCM) J217, Replacing
NOTE:
-
To achieve optimal anti-theft protection for the vehicle, an anti-theft immobilizer was installed. The anti-theft immobilizer is a system for
enabling/locking the Transmission Control Module (TCM) J217.
-
To perform adaptation of the anti-theft immobilizer.
Procedure
Check the identification of the previous Transmission Control Module (TCM) J217 as follows:
-
Connect the scan tool.
-
Switch the ignition on.
-
Select "Diagnostic mode 9: Vehicle information."
-
Select the "Test-ID 04: Calibration identification".
-
The Transmission Control Module (TCM) J217 identification will be displayed, e.g.: 09G27750 L 0301
-
End diagnosis and switch the ignition off.
Removal
-
Remove the left wheelhousing liner.
-
Disconnect the Transmission Control Module (TCM) J217 electrical harness connector - A -.
-
If equipped, disconnect the right side - 2 - and the left side - 5 - turn signal electrical harness from the Transmission Control Module (TCM) J217.
-
Remove the Transmission Control Module (TCM) J217 bracket screws - 3 -.
-
Remove the Transmission Control Module (TCM) J217 with the bracket attached.
-
Remove the bracket screws - 4 - and the bracket from the Transmission Control Module (TCM) J217.
Installation