| Description and Operation Section 100-04: Noise, Vibration and Harshness | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 100-F027 | Vibration Analyzer | - | Commercially available | | 107-R2100 | EngineEAR | - | Commercially available | | 107-R2102 | ChassisEAR | - | Commercially available | | 134-R0135 | Ultrasonic Leak Detector | - | Commercially available (Leitenberger ULG01 or equivalent) | Section 204-01: Front Suspension | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 205-014 | Pinion Bearing Cup Replacer | 205-073 | | | 205-D014 | Step Plate | 205-073 | | | 205-153 | Pinion Bearing Cone Remover | - | Not needed | | 205-D002 | Step Plate | - | Commercially available | | 205-D015 | Front Hub Replacer | 205-073 | | | 205-D069 | Front Hub Remover | 204-161 | | | 205-239 | Step Plate | 303-509 (21-213) | | | 205-278 | Step Plate | 205-074-01 (15-064) | | | 205-D070 | Front Hub Remover | 205-076 (15-038) or equivalent | | | 211-105 | Tie Rod End Remover | - | Commercially available | Section 204-02: Rear Suspension | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 204-019 | Pinion Bearing Cup Replacer | 205-074 | | | 204-020 | Bearing Cup Replacer | 205-073 | | | 204-161 (T97P-1175-A) | Halfshaft Installer | 204-161 (14-041) | | | 205-014 | Pinion Bearing Cup Replacer | 205-074 | | | 205-D070 | Front Hub Remover | 205-076 (15-038) or equivalent | | | 308-153 | Differential Bearing Cup Peplacer | 205-074 and 303-509 | | | 205-098 | Rear Axle Draw Bar | 205-074 | | | 205-D002 | Pinion Bearing Cone Remover | - | | | 205-D015 | Wheel Bearing Adapter | 308-110-01 and 205-073 | Commercially available | | 205-153 | Pinion Bearing Cone Remover | - | | | 100-001(T50T-100-A) | Impact Slide Hammer | 205-047 (15-011) or equivalent | Commercially available | Section 205-00: Driveline System - General Information | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 100-002(TOOL -4201-C) | Dial Indicator Gauge with Holding Fixture | - | Commercially available | | 100-D002 (D78P-4201-B) | Dial Indicator Gauge with Holding Fixture | - | Commercially available | | 308-021 (T75L-4201-A) | Clutch, Clutch Housing | - | Commercially available | | 100-F027 (014-00344) or equivalent | Vibration Analyzer | - | Commercially available | Section 205-01: Driveshaft | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 100-D002 (D78P-4201-B) | Dial Indicator Gauge with Holding Fixture | - | Commercially available | | 205-086 (T74P-4635-C) | Installer/Remover, C-Frame and Screw | 204-288 | | Section 205-02: Rear Drive Axle/Differential | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 100-001(T50T-100-A) | Impact Slide Hammer | 205-047 (15-011) or equivalent | | | 205-126 (T78P-4851-A) | Holding Fixture, Drive Pinion Flange | 205-072 (15-030A) or equivalent | | | 205-133 (T79P-4676-A) | Pinion Seal Replacer | 308-095 (16-038) or equivalent | | | 205-153 (T80T-4000-W) | Adapter for 303-224 (Handle) | 307-210 (17-041) | | | 205-195 (T83T-1244-A) | Installer, Axle Bearing | 307-210 (17-041) | | | 205-350 ((T95T-3010-A) | Installer, Front Axle Oil seal | 307-028 (17-002) | | | 205-D072 (D97L-4221-A) | 2 Jaw Puller | - | Commercially available | | 307-309 (T94P-77001-BH) | Remover, Torque Converter Fluid Seal | 307-272 (17-061) or equivalent | | | 307-009 (T94P-77001-BH) | Converter Seal Remover | 307-272 (17-061) or equivalent | | | 308-125 (T87P-7120-D) | Remover, Transfer Case Bearing Cup | | | Section 205-04: Front Drive Halfshafts | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 205-343 (T95P-3514-A) | Installer, CV Boot Clamp | 204-169 or equivalent | | | 100-001(T50T-100-A) | Impact Slide Hammer | 205-047 (15-011) or equivalent | | | 204-161 (T97P-1175-A) | Halfshaft Installer | 204-161 (14-041) | | | 205-241 (T86P-3514-A) | Puller, CV Joint | - | Commercially available | | 205-D070 (D93P-1175-B) | Remover, Front Wheel Hub | 205-076 (15-038) or equivalent | | Section 205-05: Rear Drive Halfshafts | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 205-343 (T95P-3514-A) | Installer, CV Boot Clamp | 204-169 (14-044) or equivalent | Clamping Tool, Boot Retaining Clamp | | 204-161 (T97P-1175-A) | Halfshaft Installer | 204-161 (14-041) | Installer, Halfshaft | | 205-241 (T86P-3514-A) | Puller, CV Joint | 205-047 and 204-226 and 204-226-01 | | | 205-D070 (D93P-1175-B) | Remover, Front Wheel Hub | 205-076 (15-038) or equivalent | | Section 206-00: Brake System - General Information | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 201-00002 | On-Car Brake Lathe | - | Commercially available | | 416-D002 (D95L-7559-A) | Vacuum Pump | 416-D001 (23-036A) | Hand Vacuum/Pressure Pump | Section 206-05: Parking Brake and Actuation | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 206-D002 (D81L-1103-A) | Brake Adjusting Gauge | - | Commercially available | Section 206-09: Anti-Lock Control | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R025B | Flex Probe Kit | 418-S035 or equivalent | | | 105-R0057 | 73III Automotive Meter | - | Commercially available | Section 211-00: Steering System - General Information | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 023-R0007 | Dial Thermometer 0-220°F | - | Commercially available | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 211-001 (TOOL-3290-D) | Tie-Rod End Remover | 204-349+211-020 or equivalent | | | 211-034 ((T74P-3504-Y) | Gauge, Spring Tension | - | Commercially available | | 211-F001 (014-00207) | Power Steering Analyzer | 211-190 or equivalent | | | 418-F102 (007-00061) | DIS/EDIS Tach Adapter | - | Commercially available | | 211-265 | Evcuation Cap, Power Steering | - | Commercially available | | 211-327 | Fill Adapter Maniford, Power Steering | - | Commercially available | | 416-D002 (D95L-7559-A) | Vacuum Pump | 416-D001 (23-036A) | Hand Vacuum/Pressure Pump | Section 211-02: Power Steering | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 211-016 (T69L-10300-B) | Remover, Power Steering Pump Pulley | 211-198 (13-021) | Remover, Power Steering Pump Pulley | | 211-105 (T85M-3395-A) | Tie-Rod End Remover | - | Commercially available | | 211-185 (T91P-3A733-A) | Installer, Power Steering Pump Pulley | 303-458 | | Section 211-03: Steering Linkage | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 211-105 (T85M-3395-A) | Tie-Rod End Remover | - | Commercially available | Section 211-05: Steering Column Switches | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive meter | - | Commercially available | | 105-R025B | Flex Probe Kit | 418-S035 or equivalent | | Section 303-00: Engine System - General Information | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 014-00708 | Engine Cylinder Leak Detection/Air Pressurization Kit | - | Commercially available | | 100-002(TOOL -4201-C) | Dial Indicator Gauge with Holding Fixture | 205-064+205-070 or equivalent | Commercially available | | 134-R0212 | Quick Disconnect Compression Tester | - | Commercially available | | 164-R0253 | Vacuum/Pressure Tester | 416-D001 or equivalent | Commercially available | | 164-R0756 | 12 Volt Master UV Diagnostic Inspection Kit | - | Commercially available | | 303-088 (T73L-6600-A) | Oil Pressure Gauge | GV2134 or equivalent | | | 100-001(T50T-100-A) | Impact Slide Hammer | 205-047 (15-011) or equivalent | | | 303-006 (TOOL-6513-DD) or equivalent | Pressure Gauge, Valve/Clutch Spring | - | Commercially available | | 303-D027 (D81L-4201-A) | Feeler Gauge Set | - | Commercially available | | 303-D039 (83L-4201-A) | Straight Edge | - | Commercially available | Section 303-01A: Engine - 2.3L | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 014-0001 | Universal Adapter Brackets | - | Not needed | | 014-00071 | Heavy Duty Floor Crane | - | Commercially available | | 014-00232 | Engine Stand | 303-435 or equivalent | | | 014-00765 | Powertrain Lift | - | Commercially available | | 205-072-02 | Adapter for 205-126 | 205-072 and 205-072-02 | | | 205-126 (T78P-4851-A) | Holding Fixture, Drive Pinion Flange | 205-072 | | | 303-096 (T74P-6150-A) | Installer, Front Oil Seal | 303-395 and 205-071-02 and 308-208 | | | 303-300 (T87C-6565-A) | Compressor, Valve Spring | 303-361, 303-362, 303-361-02 and 303-363 | | | 303-328 (T88P-6701-B1) | Installer, Crankshaft Rear Main Oil Seal | Installation tool is part of the rear oil seal | Not needed | | 303-350 (T89P-6565-A) | Compressor, Valve Spring | 303-361, 303-362, 303-361-02 and 303-363 | | | 303-409 (T92C-6700-CH) | Remover, Oil Seal | 303-293 | | | 303-465 (T94P-6256-CH) | Alignment Plate, Camshaft | 303-376B | | | 303-468 (T94P-6510-AH) | Remover, Valve Stem Oil Seal | 303-508 | | | 303-470 (T94P-6510-CH) | Installer, Valve Stem Oil Seal | 303-508 | | | 303-472 (T94P-6565-AH) | Compressor, Valve Spring | 303-361, 303-362, 303-361-02 and 303-363 | | | 303-507 | Timing, Peg, Crankshaft | 303-507 | | | 303-D089 (D93P-6001-A3) | Spreader Bar | 303-122 | | | 303-D095 (D94L-6001-A) or equivalent | Lifting Bracket Set, Engine | 303-240A, 303-290-05A, 303-290-03A | | | 303-F072 | Three Bar Engine Support Kit | 303-240A, 303-290-05A, 303-290-03A | | | 307-005 (T59L - 100-B) | Slide Hammer | - | Not needed | | 308-006 (T71P-7137-H) | Aligner, Clutch Disc | 308-204 or equivalent | | Section 303-01B: Engine - 3.0L | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 211-185 (T91P-3A733-A) | Installer, Power Steering Pump Pulley | 303-458 | | | 303-009 (T58P-6316-D) | Remover, Crankshaft Vibration Damper | 303-338 and 303-338-02 | | | 303-050 (T70P-6000) | Lifting Brackets, Engine | - | Commercially available | | 303-050 (T70P-6000) | Replacer, Crankshaft Damper | 303-461-01 and 303-362 | | | 303-102 (T74P-6316-B) | Installer, Crankshaft Rear Main Oil Seal | 303-130 and 303-055 | | | 303-178 (T82L-6701-A) | Installer, Crankshaft Rear Main Oil Seal | 303-460 | | | 303-300 (T87C-6565-A) | Compressor, Valve Spring | 303-461 | | | 303-335 (T88T-6701-A) | Valve Spring Compressor | 303-130 and washer | | | 303-384 (T91P-6701-A) | Installer Bolts, Crankshaft Rear Main Oil Seal | Flywheel bolt | | | 303-409 (T92C-6700CH) | Remover, Oil Seal | 303-293 | | | 303-463 (T94P-6256-AH) | Installer, Camshaft Oil Seal | 303-458-01 | Adaptor for 303-458 (21-192) | | 303-464 (T94P-6256-BH) | Valve Stem Seal Replacer | - | Not needed | | 303-470 (T94P-6510-CH) | Installer, Valve Stem Oil Seal | 303-247 | | | 303-519 (T95P-6701-EH) | Remover, Crankshaft Rear Seal | 303-293 | | | 303-D055 (D85L-6000-A) | Strap Wrench | 303-254 | | | 303-D089 (D93P-6001-A3) | Spreader Bar | 303-122 | | | 303-S455 (T94P-6312-AH) | Service Set, Water Pump Pulley | 303-458 | | | 307-005 (T59L - 100-B) | Slide Hammer | - | Not needed | | 303-473 (T94P-6565-BH) | | - | Not needed | | 303-F072 | Three Bar Engine Support Kit | 303-240A, 303-290-05A, 303-290-03A | | | 307-005 (T59L - 100-B) | Slide Hammer | - | Not needed | | 014-0001 | Universal Adapter Brackets | | | | 014-00765 | Powertrain Lift | - | Commercially available | Section 303-03: Engine Cooling | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 014-R1060 | Battery/Anti-Freeze Tester | - | Commercially available | | 014-R1072 | Radiator Pressure Tester | 303-396 and 303-396-05 or equivalent | | | 023-R0007 | Dial Thermometer 0 - 220° F | - | Commercially available | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | | | | | | 418-F224 | Worldwide Diagnostic System (WDS) | WDS / FDS2000 | | | 078-00497 | RADKITPLUS | - | Commercially available | Section 303-06: Starting System | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 010-00725 | Alternator, Regulator, Battery and Starter Tester (ARBST) | - | Commercially available | | 105-R0057 | 73III Automotive Meter | - | Commercially available | Section 303-13: Evaporative Emissions | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 218-0002 or equivalent | VACUTEC Smoke Machine Fuel EVAP Emissions System Tester | - | Commercially available | Section 303-14: Electronic Engine Controls | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 303-476 (T94P-9472-A) | Socket, Exhaust Gas Oxygen Sensor | 310-063 | | | 303-507 | Timing, Peg, Crankshaft | 303-507 | | Section 307-01: Automatic Transmission/Transaxle | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73 III Digital Multimeter | - | Commercially available | | 164-R0751 | 12 Volt UV Spot Lamp Kit | - | Commercially available | | 307-301 (T94P-77000-S) (17-056) | Air Test Plate, Transmission | 307-301 | | | 307-351 (T97L-70010-A) | Alignment Gauge, TR Sensor | 307-351 | | | 307-F016 ( 007-00130) | Transmission Tester | - | Not needed. Use Mondeo 2001(10/00-) CD4E Diagnostic Strategy | | 418-F052, or equivalent scan tool | New Generation STAR (NGS) Tester | WDS / FDS2000 | | | 418-F113 (007-00125) | CD4E Cable | - | Not needed. Use Mondeo 2001(10/00-) CD4E Diagnostic Strategy | | 418-F117 (007-00129) | MLP-D Cable | - | Not needed. Use Mondeo 2001(10/00-) CD4E Diagnostic Strategy | | 418-F224 New Generation Star (NGS) Tester 418-F052 or equivalent | Worldwide Diagnostic System (WDS) | WDS / FDS2000 | | | 100-001(T50T-100-A) | Impact Slide Hammer | 205-047 (15-011) or equivalent | | | 100-010 (T71P-19703-C) | Remover, O-Ring Seal | 100-010 | | | 303-D011 (D80L-100-G) | Actuator Pin (Dia 3/16 Inch) | - | Commercially available | | 303-D019 (D80L-100-Q) | Collet, 3/4 to 7/8 Inch | - | Commercially available | | 307-003 (T57L-500-B) | Holding Fixture, Transmission | 303-435-13A | | | 307-091 (T81P-7902-C) | Handle, Torque Converter | - | Not needed. Use Mondeo 2001(10/00-) CD4E Diagnostic Strategy | | 307-109 (T81P - 78103 - A) | Cross Block | - | Commercially available | | 307-288 (T94P-77000-F) | Holding Fixture, Transmission | 303-435-06 and 303-435 | | | 307-289 (T94P-77000-G) | Remover, Transmission Fluid Pump | - | Commercially available | | 307-295 (T94P - 77000 - L) | Remover/Installer, Servo Cover | 204-168 and clamp | | | 307-309 (T94P-77001-BH) | Remover, Torque Converter Fluid Seal | 307-309 | | | 307-346 (T97T - 7902 - A) | Retainer, Torque Converter | - | Not needed. Use Mondeo 2001(10/00-) CD4E Diagnostic Strategy | | 308-375 | Remover, Input Shaft Oil Seal | 307-272 | | | 100-001(T50T-100-A) | Impact Slide Hammer | - | Not needed. Use Mondeo 2001(10/00-) CD4E Diagnostic Strategy | | 308-125 (T87P-7120-D) | Remover, Transfer Case Bearing Cup | - | Commercially available | | 307-294 (T94P-77000-K) | Installer, Needle Bearing | 307-294 | | | 205-153 (T80T-4000-W) | Adapter for 303-224 (Handle) | 205-101 | | | 308-201 (T91T-7127-A) | Remover, Input Shaft Bearing | - | Commercially available | | 307-306 (T94P-77000-U1) | Installer, Lube Tube | 307-307 | | | 307-293 (T94P-77000-J) | Installer, Transmission Sprag | - | Not needed. Use Mondeo 2001(10/00-) CD4E Diagnostic Strategy | | 100-D002 (D78P-4201 - B) | Dial Indicator Gauge with Holding Fixture | - | Commercially available | | 307-282 (T94P-77000-D3) | Protector, Piston Seal | 307-282 | | | 307-345 (T96P-77000-A) | Protector, Piston Seal | - | Not needed. Use Mondeo 2001(10/00-) CD4E Diagnostic Strategy | | 307-015 (T65L-77515-A) | Compressor, Clutch Spring | 307-015 | | | 100-010 (T71P-19703-C) | Remover, O-Ring Seal | 100-010 | | | 307-283 (T94P-77000-D4) | Sizer, Hub Seal | 307-283 | | | 307-299 (T94P-77000-N) | Alignment Pins, Valve Body | 307-299 | | | 307-240 (T91P-76085-A) | Installer, lube Tube Fluid Seal | 204-058 | | | 307-286 (T94P-77000-E1) | Remover/Installer , Needle Bearing | 307-286 | | | 307-287 (T94P-77000-ER 2) | Remover/Installer Servo Plug | 205-297 | | | 307-097 (T81P-70337-A) | Installer, Throttle Shaft Fluid Seal | 204-018 | | | 100-010 (T71P-19703-C) | Remover, O-Ring Seal | 100-010 | | | 205-098 (T75T-1176-A) | Drawbar, Rear Axle | 205-074 | | | 307-307 (T94P-77000-U2 | Installer, Lube Tube | 307-307 | | | 303-D026 (D80P-4201-A) | Depth Micrometer | 307-300-02 | | | 307-300 (T94P - 77000 - Q) | Shim Selection Gauge | 307-300 | | | 307-127 (T94P - 77000 - P) | Alignment Pins , Transmission Main Control Body | 307-127 | | | 307-281 (T94P - 77000 - D2) | Protector, Piston Seal | 307-281 | | | 307-015 (T65L-77515-A) | Compressor, Clutch Spring | 307-015 | | | 307-S290 (T94P-77000-H) | Aligner, Selector Shaft | 307-S290 | | | 308-375 | Remover, Input Shaft Oil Seal | 308-208 | | | 307-157 (T86P-1177-B) | Installer, Halfshaft Output Fluid | 205-177 | | | 307-429 | Remover, RH Halfshaft Fluid Seal | 308-208 | | | 307-428 | Installer, RH Halfshaft Fluid Seal | 205-077 | | | 307-351 (T97L-70010-A) | Alignment Gauge, TR Sensor | 307-351 | | | 307-295 (T94P - 77000 - L) | Remover/Installer, Servo Cover | 204-168 and clamp | | | 303-290A-03A | Adapter for 303-290A (Support Leg ) | 303-290A-03A | | | 303-290A | Support Bar, Engine | 303-290A | | | 303-290A-01 | Adapters for 303-290 | 303-290A-01 | | | 303-D089 (D93P-6001-A3) | Engine Lifting Chains (Part of Spreader Bar) | 303-290-07 | | Section 307-05: Automatic Transmission/Transaxle External Controls | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73 III Digital Multimeter | - | Commercially available | Section 308-00: Manual Transmission/Transaxle and Clutch - General Information | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 100-D002 (D78P-4201 - B) | Dial Indicator Gauge with Holding Fixture | - | Commercially available | Section 308-01 : Clutch | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 303-103 (T74P-6375-A) | Flywheel Holding Tool | 303-254 | | | 308-020 (T74P-7137-K) | Clutch Aligner | 308-204 | | Section 308-03: Manual Transmission/Transaxle | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 100-002(TOOL -4201-C) | Dial Indicator Gauge with Holding Fixture | 205-064+205-070 or equivalent | Commercially available | | 205-153 (T80T-4000-W) or equivalent | Adapter Handle | Black Box | Black Box | | 308-097 (T85T-7011-A) or equivalent | Installer, Oil Seal | Black Box | Black Box | | 308-579 or equivalent | Installer, Output Shaft Seal | Black Box | Black Box | | 100-001 (T50T-100-A) or equivalent | Slide Hammer | 205-047 (15-011) or equivalent | | | 308-047 (T77F-1102-A) or equivalent | Bearing Cup Remover | - | Commercially available | | 100-D002 (D78P-4201-B) or equivalent | Dial Indicator Gauge with Holding Fixture | - | Commercially available | | 205-090 | Bearing/Oil Seal Plate | Black Box | Black Box | | 205-199 | Installer, Spindle/Axle Shaft | Black Box | Black Box | | 205-D035 | 2-Jaw Puller | - | | | 205-D064 | Puller, Bearing | - | | | 308-580 | 2nd Gear Bushing Installer | Black Box | Black Box | | 308-581 | 6th Gear Bushing Installer | Black Box | Black Box | | 308-582 | Input Bearing Installer | Black Box | Black Box | | 303-F072 | Three-Bar Engine Support Kit | 303-240A, 303-290-05A, 303-290-03A | | | 308-597 | Installer, Output Shaft Seal | 308-597 | | Section 308-07A: Four-Wheel Drive Systems | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 or equivalent | 73 I I I Automotive Meter | - | Commercially available | | 418-F224, New Generation STAR (NGS) Tester 418-F052, or equivalent diagnostic tool | Worldwide Diagnostic System (WDS) | WDS / FDS1999 | | | 418-F052, or equivalent scan tool | New Generation STAR (NGS) Tester | WDS / FDS2000 | | Section 308-07B: Transfer Case | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 308-584 | Installer, Vent Tube | - | Commercially available | | 100-001(T50T-100-A) | Impact Slide Hammer | 205-047 (15-011) or equivalent | | | 205-126 (T87P-4851-A) | Holding Fixture, Drive Pinion Flange | 205-072 (15-030A) | Flange Holding Wrench, Universal | | 205-153 (T80T-4000-W) Adapter for 303-224 (Handle) | Adapter for 303-224 (Handle) | - | Not needed | | 205-155 (T80T-4000-Y) | Installer, Rear Axle Oil Seal | 204-288 (14-063) | Remover/Installer, Ball Joint | | 211-014 (T67L-3600-A) or commercial | | 211-014 (13-019) | Remover, Steering Wheel | | 308-427 | Remover, PTO Driven Gear Oil Seal | 205-296 (15-085) | Installer, Rear Hub Bearing Cone/Oil Seal | | 308-428 | Remover, Halfshaft Oil Seal | - | Commercially available | | 308-429 | Installer, Halfshaft Oil Seal | 308-113 (16-044) | Installer, Input Shaft Oil Seal | | 308-430 | Installer, PTO Drive Gear Outer Oil Seal | 308-604/2 | | | 308-431 | Installer, Halfshaft Oil Seal | 205-064 (15-028) | Socket, Axle Nut (65 mm) | | 308-432 | Installer, PTO Dust Flange | 308-013 (16-008) | Remover/Installer, Mounting Bushing | Section 309-00: Exhaust System | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 303-476 (T94P-9472-A) | Socket, Exhaust Gas Oxygen Sensor | 310-063 | | | 309-D002 (D95L-6000-A) or equivalent | Exhaust Back Pressure Gauge | - | Commercially available | | 303-D039 (D83L-4201-A) or equivalent | Straight Edge | - | Commercially available | Section 310-01: Fuel Tank and Lines | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 164-R3202 or equivalent | Fuel Storage Tanker | - | Commercially available | | 310-102 | Fuel Drain Hose | - | Commercially available | | D80-23200-A or equivalent | Heavy Duty Riveter | - | Commercially available | Section 310-03: Vehicle Speed Control | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73 III Digital Multimeter | - | Commercially available | | 418-F468 | Diagnostic Tool, Restraint System (4 Req'd) | 418-F468 | | Section 412-00: Climate Control System - General Information | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 023-00047 or equivalent | R-134a Manifold Gauge Set | - | Commercially available | | 023-00155 or equivalent | Automatic Refrigerant Charging Meter | - | Commercially available | | 023-00162 or equivalent | 1.2 CFM Vacuum Pump | - | Commercially available | | 023-00163 or equivalent | 4.0 CFM Vacuum Pump | - | Commercially available | | 023-00174 or erquivalent | R-134a Refrigerant Center | - | Commercially available | | 164-R0721 or equivalent | 120 Watt UV Spot Lamp | - | Commercially available | | 164-R0775 or equivalent | Dye/ Lubricant Injector | - | Commercially available | | 164-R6000 or equivalent | High Intensity UV Lamp - 12 Volt | - | Commercially available | | 164-R6060 | R-134a Leak Detection Dye | - | Commercially available | | 167-R4700 or equivalent | 30oz Sure Shot Pressure Sprayer | - | Commercially available | | 176-00002 or equivalent | R-134a Refrigerant Center | - | Commercially available | | 198-00003 or equivalent | Refrigerant Indentifier with Air-Radicator | - | Commercially available | | 216-00001 or erquivalent | H10PM Refrigerant Leak Detector With Battery | - | Commercially available | | 219-00022 (part of 219-00023) or equivalent | A/C Flush and Purge Machine | - | Commercially available | | 219-00024 ( part of 219-00023) or equivalent | A/C Flush and Purge Fitting Kit | - | Commercially available | | 219-00069 or equivalent | Deluxe Loop Kit Add-On Module Kit | - | Commercially available | | 412-039 (T84L-19623-B) 5/8 (Black T80P19623C) Blue or Green 1/2" 412-038 | | 412-027 and 412-038 | Disconnect Tool, Spring Lock Coupling (1/2" blue) | | 412-DS028 (D93L-19703-B) or equinalent | Set, A/C Fittings | - | Commercially available | | 416-D002 (D95L-7559-A) or equivalent | Vacuum Pump Kit | 416-D001 (23-036A) | Hand Vacuum/Pressure Pump | Section 412-03: Air Conditioning | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 205-D026 (D80L-1002-L) or equivalent | 2-Jaw Puller | - | Commercially available | | 412-065 (T89P-19623-EH) | Coil Replacer | 205-342-02 | | | 205-116 (T77F-4220-B1) | Differential Bearing Cone Remover | - | Commercially available | | 412-034 (T38L-19990-A) | Remover/Installer, Fixed Orifice | 412-034 | | | 412-035 (T83L-19990-B) | Remover, Broken Orifice | 412-035 | | | 412-078 (T91L-19623-CH) | Field Coil Replacer | 205-342-02 | | | 412-067 (T89P-19623-FH) | Field Coil Remover | 205-071-01 | | | 412-098 (T94P-19703-AH) | Compressor Clutch Holding Tool | - | Commercially available | Section 413-00: Instrument Cluster and Panel Illumination | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 413-01: Instrument Cluster | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | | 014-R1063 | | - | Commercially available | Section 413-06: Horn | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 413-09: Warning Devices | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 414-00: Charging System - General Information | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 010-00736 | SABRE Premium Electrical System Tester | - | Commercially available | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 414-01: Battery, Mounting and Cables | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 162-00004 | Micro 490 Digital Battery Analyzer | - | Commercially available | Section 415-00: Entertainment System - General Information | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | Section 415-01: Audio Unit | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 415-001 (T87P-19061-A) | Radio Removal Tool | - | Commercially available | Section 417-01: Exterior Lighting | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 417-02: Interior Lighting | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 418-00: Module Communications Network | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 418-01: Module Configuration | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 419-01A: Anti-Theft - Active | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 419-01B: Anti-Theft - Passive | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 419-10: Multifunction Electronic Control Modules | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 501-09: Rear View Mirrors | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 501-10: Seating | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 501-010 (T77L-2100-A) | Torx Bit, Safety Belt Bolt | Torx T 50 | Commercially available | Section 501-11: Glass, Frames and Mechanisms | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 107-R0300 or equivalent | Heat Gun | - | Commercially available | | 107-R1511 | Interior Auto Glass Cut-Out Knife Kit | - | Commercially available | | 164-R2450 | Interior Auto Glass Cut-Out Knife Kit (Electric) | - | Commercially available | | 164-R2459 or equivalent | The Pumper | - | Commercially available | Section 501-12: Glass, Frames and Mechanisms | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 412-D024 (D91P-19703-A) , or equivalent | Alignment Pin, Temperature Blend Door | - | Commercially available | Section 501-14: Handles, Locks, Latches and Entry Systems | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | Section 501-17: Roof Opening Panel | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | Section 501-19: Bumpers | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 501-D011 (D80L-23200-A) | Heavy Duty Riveter | - | Commercially available | Section 501-20A: Occupant Restraints - Active | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 100-F012 (134-00018) | D-Ring Installation Kit or equivalent | - | Commercially available | | 501-010 (T77L-2100-A) | Torx Bit, Safety Belt Bolt | Torx T 50 | Commercially available | Section 501-20B: Occupant Restraints - Passive | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 105-R0057 | 73III Automotive Meter | - | Commercially available | | 418-F052 | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | | 418-F403 | Diagnostic Tool, Restraint System (2 Req'd) | 418-F403 | | | 418-FS317 New Generation STAR (NGS) Tester 418-F052, or equivalent scan tool | Worldwide Diagnostic System (WDS) | - | Worldwide Diagnostic System (WDS) | | 418-133 (014-R1076) | Diagnostic Tool, Restraint System (4 Req'd) | 418-133 | | Section 502-00: Uni-Body, Subframe and Mounting System | North American Special Tool Number | North American Special Tool Name | European Special Tool Number | Comment | | 303-F072 | Three Bar Engine Support Kit | 303-240A, 303-290-05A, 303-290-03A | | |
