ford Workshop Repair Guides

Ford Workshop Service and Repair Manuals

ABOUT US
303-14A Electronic Engine Controls - 2.3L Duratec-HE (MI4) > < Dust Separator - Vehicles Built From: 12-2003

Maverick 2005 (08.2004-)

Evaporative Emissions - Fuel Vapor Control Tube Assembly Valve Maverick 2005 (08/2004-)
Removal and Installation

 
Item
Part Number
Description
1
9J279A
Fuel vapor tube quick connect coupling
2
9D668A
Fuel vapor tube quick connect coupling
3
9D668A
Fuel vapor quick connect coupling
4
9D668A
Fuel vapor control tube assembly valve

Removal and Installation

WARNING:
WARNING:The evaporative emission system contains fuel vapor and condensed fuel vapor. Although not present in large quantities, it still presents the danger of explosion or fire. Disconnect the battery ground cable from the battery to minimize the possibility of an electrical spark occurring, which can cause a fire or explosion if fuel vapor or liquefied fuel are present in the area. Failure to follow these instructions may result in personal injury.
  1. Remove the fuel tank. For additional information, refer to Section 310-01 Fuel Tank and Lines.
  1. Release the fuel vapor tube quick connect coupling from the fuel vapor control tube assembly valve fitting. For additional information, refer to Section 310-00 Fuel System - General Information.
  1. Release the fuel vapor control assembly valve tube quick connect coupling from the evaporative emissions (EVAP) canister vent solenoid. For additional information, refer to Section 310-00 Fuel System - General Information.
  1. Disconnect the fuel vapor control tube assembly valve quick connect coupling from the fuel filter vapor tube. For additional information, refer to Section 310-00 Fuel System - General Information.
  1. Remove the fuel vapor control tube assembly valve.
  1. To install, reverse the removal procedure.
    • Carry out the evaporative emission repair verification drive cycle. For additional information, refer to diagnostic scan tool to diagnose the system.

303-14A Electronic Engine Controls - 2.3L Duratec-HE (MI4) > < Dust Separator - Vehicles Built From: 12-2003