Ford Workshop Service and Repair Manuals > Maverick 2005 (08.2004-) > Mechanical Repairs | 5 Body and Paint | 501 Body and Paint | 501-16 Wipers and Washers | Description and Operation | Diagnosis and Testing | General Procedures | Removal and Installation | Rear Window Washer Pump

Wipers and Washers - Rear Window Washer Pump—Vehicles Built From: 12/2004

Maverick 2005 (08/2004-)

Removal and Installation

Removal and Installation

With the vehicle in NEUTRAL, position it on a hoist. For additional information, refer to Section 100-02 Jacking and Lifting.

Remove the RH front fender splash shield. For additional information, refer to Section 501-02 Front End Body Panels.

WARNING:Windshield washer solution contains methanol, which is poisonous. Observe all cautions and warnings indicated on the label of the washer solution container. Failure to follow these instructions may result in personal injury.

CAUTION:When replacing the rear window washer pump, be careful not to damage the rubber grommet.

NOTE:To prevent spilling windshield washer fluid, drain the windshield washer reservoir before washer pump removal.

Remove the rear window washer pump.
1. Disconnect the electrical connector.
1. Disconnect the hose.
1. Remove the rear window washer pump.

WARNING:Windshield washer solution contains methanol, which is poisonous. Observe all cautions and warnings indicated on the label of the washer solution container. Failure to follow these instructions may result in personal injury.

CAUTION:Do not operate the windshield washer pump prior to filling the windshield washer reservoir. Failure to follow these instructions may result in premature pump failure.

To install, reverse the removal procedure.
- Fill the windshield washer reservoir with windshield washer fluid.

Ford Workshop Service and Repair Manuals