Savana 1/2 Ton Van V8-5.7L VIN R (2001)
1. Remove peel-off liner from saturated foam.
2. Spray 85 percent alcohol 15 percent water mixture per GM 9981293 on saturated foam patch.
3. Locate the part by lining up the two pins (1) on the top of the weatherstrip with the holes in the door sheet metal.
4. Insert the pocket over the door flange and push down the pins until they are fully seated and there are no gaps between the door and the
weatherstrip (3).
5. Insert the pin that is located on the pocket into the door sheet metal until it is fully seated and there is no gap between the door and the weatherstrip
.
6. Complete the installation by tucking the bottom inner edge of the weatherstrip (3) into the top door flange.
Side Door Opening Weatherstrip Replacement
Side Door Opening Weatherstrip Replacement
Removal Procedure
1. Remove the hinge pillar upper garnish. Refer to Upper Pillar Garnish Molding Replacement (See: Interior Moulding / Trim/Trim Panel/Service
and Repair/Upper Pillar Garnish Molding Replacement) in Interior Trim.
2. Remove the hinge pillar lower garnish molding. Refer to Lower Pillar Garnish Molding Replacement (See: Interior Moulding / Trim/Trim
Panel/Service and Repair/Lower Pillar Garnish Molding Replacement) in Interior Trim.
3. Remove the side door opening frame garnish molding. Refer to Side Door Opening Frame Garnish Molding Replacement (See: Interior Moulding
/ Trim/Trim Panel/Service and Repair/Side Door Opening Frame Garnish Molding Replacement) in Interior Trim.
4. Remove the passenger side front corner garnish molding. Refer to Center Pillar Upper Garnish Molding Replacement - Right Side (See: Interior
Moulding / Trim/Trim Panel/Service and Repair/Center Pillar Upper Garnish Molding Replacement - Right Side) in Interior Trim.
5. Remove the passenger side body side trim panel. Refer to Body Side Trim Panel Replacement - Right Side (See: Interior Moulding / Trim/Trim
Panel/Service and Repair/Body Side Trim Panel Replacement - Right Side) in Interior Trim.
6. Remove the side door stepwell mat. Refer to Front Side Door Step Mat Replacement (See: Interior Moulding / Trim/Carpet/Service and
Repair/Mat Replacement - Stepwell) in Interior Trim.
7. Remove the retainers at the lower corners of the side door opening weatherstrip.
