L322 Range Rover Service Procedures
PANEL REPAIRS
-22
REPAIRS
Refit
1. LH side: Fit windscreen washer reservoir.
Reservoir - combined windscreen/
headlamp washer.
2. Diesel models: Fit and connect intercooler
pipes.
3. RH side: Fit gearbox fluid cooler.
5L40-E, REPAIRS, Gearbox fluid cooler.
4. LH side: Fit radiator expansion tank.
5. Fit radiator.
6. Fit front armature.
7. Fit front bumper assembly.
8. Fit underbelly panel.
9. Connect alternator.
10. Connect battery earth lead.
Front sidemember (front section)
In this procedure, the front section of the front
sidemember inner panel, front sidemember outer
panel and the front sidemember reinforcement panel
are replaced.
Remove
1. Disconnect battery earth lead.
2. Disconnect alternator.
3. Remove underbelly panel.
4. Remove front bumper assembly.
5. Remove front armature.
6. Remove radiator.
7. LH side: Remove radiator expansion tank.
8. Recover refrigerant from A/C system.
RECOVERY, RECYCLING AND
RECHARGING, Refrigerant recovery -
recycling and recharge.
NOTE: Receiver drier need only be changed
under the following circumstances. There is dirt
in the refrigerant circuit ( e.g. compressor
seizure ). The system is leaking and refrigerant
has been lost to atmosphere. Refrigerant
circuit has been open more than 24 hours due
to repair.
9. Remove A/C pipes from sidemember.
10. RH side: Remove gearbox fluid cooler.
5L40-E, REPAIRS, Gearbox fluid cooler.
11. Diesel models: Release and remove
intercooler pipes.
12. LH side: Remove windscreen washer
Reservoir - combined windscreen/
headlamp washer.
13. LH side: Remove alternator.
14. Remove front wheel arch liner.
15. Remove PAS pipes to access panel.
