Astra L4-1.8L (2009)
17. Disconnect the SIR deployment harness from the power source after the inflator module deploys.
18. If the inflator module did not deploy, disconnect the adapter and discontinue the procedure and contact the Technical Assistance Group.
If deployment was successful, proceed to the following steps.
Warning: Refer to SIR Deployed Inflator Modules Are Hot Warning (See: Service Precautions/SIR Deployed Inflator Modules Are Hot
Warning).
19. Seat one banana plug into the other in order to short the deployment harness leads.
20. Put on a pair of shop gloves.
21. Disconnect the pigtail adapter from the inflator module as soon as possible.
22. Inspect the pigtail adapter and the SIR deployment harness. Replace as needed.
23. Dispose of the deployed inflator module through normal refuse channels.
24. Wash your hands with a mild soap.
Deployment Inside Vehicle - Vehicle Scrapping Procedure
Deploy the inflator modules inside of the vehicle when destroying the vehicle or when salvaging the vehicle for parts. This includes, but is not limited to,
the following situations:
*
The vehicle has completed all useful life.
*
Irreparable damage occurred to the vehicle in a non-deployment type accident.
*
Irreparable damage occurred to the vehicle during a theft.
*
The vehicle is being salvaged for parts to be used on a vehicle with a different VIN, as opposed to rebuilding as the same VIN.
Warning: Refer to SIR Inflatable Module Deployment Outside Vehicle Warning (See: Service Precautions/SIR Inflatable Module Deployment
Outside Vehicle Warning).
1. Lower the driver and passenger windows.
2. Turn the ignition switch to the OFF position and remove the ignition key.
3. Check that all inflator modules which will be deployed are mounted securely.
4. Remove all loose objects from the front seats.
Warning
A deployed dual stage inflator module will look the same whether one or both stages were used. Always assume a deployed dual stage inflator module
has an active stage 2. Improper handling or servicing can activate the inflator module and cause personal injury.
5. Disconnect the steering wheel module yellow connector (1) from vehicle harness yellow connector (3).
