No.
|
TECH 1 Display
|
Conditions for
Checking
|
Nominal Value
|
Trouble Codes
|
Terminal
|
30
|
FUEL PUMP
|
Ignition ON
|
INACTIVE 12V
|
-
|
1/2
|
|
RELAY
|
Engine running at idle speed
|
ACTIVE 0V
|
|
12-pin
|
|
|
|
|
|
|
|
|
25 DT always:
|
ACTIVE 0V
|
|
|
|
|
|
|
|
|
Notes for Trouble-shooting:
|
Nominal Value:
|
Cause of Fault:
(If nominal value is not attained)
|
Only for vehicles with MOTRONIC and SIMTEC engine
management systems.
|
|
|
|
|
|
· Ignition OFF
|
|
|
· Release wiring harness plug and
disconnect from engine control unit K61 (MOTRONIC) or K69 (SIMTEC)
|
|
|
· Release and disconnect 12-pin MID
wiring harness plug
|
|
|
|
|
|
· Using multimeter, measure voltage to
ground in 12-pin MID wiring harness plug Ter. 1:
|
lower than 2 V
|
|
|
|
|
· Using multimeter, measure resistance to
ground at 12-pin MID wiring harness plug Ter. 1:
|
higher than 1.3 kW
|
· MOTRONIC: Short circuit to +
battery voltage or to ground in lead between 12-pin MID wiring harness plug
Ter. 1 and fuel pump relay K44/Ter. 86 or engine control unit K61/Ter. 3
(via wiring harness plug connection X3/Ter. 9)
|
|
|
· MOTRONIC: Short circuit to + battery
voltage or to ground in lead between 12-pin MID wiring harness plug Ter. 1
and fuel pump relay K44/Ter. 85 or engine control unit K69/Ter. 15 (via
wiring harness plug connection X3/Ter. 9)
|
|
|
|
· Connect following terminals to ground
in engine control unit wiring harness plug:
|
|
|
K61/Ter.
3 (MOTRONIC)
|
|
|
K69/Ter.
15 (SIMTEC)
|
|
|
|
|
|
· Measure resistance to ground in 12-pin
MID wiring harness plug Ter. 1:
|
lower than 2 W
|
· MOTRONIC: Interruption in lead
between 12-pin MID wiring harness plug Ter. 1 and fuel pump relay
K44/Ter. 86 or engine control unit K61/ Ter. 3 (via wiring harness plug
connection X3/Ter. 9)
|
|
|
· SIMTEC: Interruption in lead
between 12-pin MID wiring harness plug Ter. 1 and fuel pump relay
K44/Ter. 85 or engine control unit K69/Ter. 15 (via wiring harness
plug connection X3/Ter. 9)
|
|
|
|
Further
possible faults
|
|
· MID
|
|
|
· Engine control unit K61 or K69
|
|
|
· Relay K44
|
|
|
|
25 DT
engine:
|
|
|
Omitted, no
connection
|
|
|
|
|
|
|
|
|
|
|
|
|