TL V6-3.2L (2004)
Sunroof / Moonroof Windguard: All Technical Service Bulletins
Body - Slapping/Ticking/Tapping From Moonroof Area
07-011
February 15, 2007
Applies To:
2004-07 TL - ALL
Rattle, Slapping, or Tapping From Moonroof While Driving
SYMPTOM
There is a rattle, slapping, or tapping from the front of the moonroof while driving with the moonroof closed.
PROBABLE CAUSE
The moonroof deflector slaps against the moonroof frame.
CORRECTIVE ACTION
Insulate the moon roof deflector with wool felt.
REQUIRED MATERIALS
Wool Felt (enough to repair about 55 vehicles):
P/N 06993-SA5-000
WARRANTY CLAIM INFORMATION
In warranty:
The normal warranty applies.
Operation Number:
8140A5
Flat Rate Time:
0.3 hour
Failed Part:
P/N 70500-SEP-AO1
Defect Code:
07408
Symptom Code:
04216
Template ID:
07-O11A
Skill Level:
Repair Technician
Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone
Office. You must request consideration, and get a decision, before starting work.
DIAGNOSIS
Test-drive the client's vehicle to confirm the complaint. If you hear a slapping or tapping noise at the front of the moonroof opening with the moon roof
closed, open the sunshade and place your hand on the wind deflector. If the noise stops, go to the REPAIR PROCEDURE. If the noise does not go away,
refer to the applicable service manual for more information.
REPAIR PROCEDURE A
1.
Open the moonroof fully to allow the wind deflector to rise to its full height.
2.
Cut three 20 mm x 30 mm strips of the wool felt.
