7 Series E38 728iL Saloon (M52TU): 2 Repair Instructions
Also for this vehicle: 7 Series E38 725tds (M51) SAL, 7 Series E38 728i (M52) SAL, 7 Series E38 728i (M52TU) SAL, 7 Series E38 728iL (M52) SAL, 7 Series E38 730d (M57) SAL, 7 Series E38 730i (M60-1) SAL, 7 Series E38 730iL (M60-1) SAL, 7 Series E38 735i (M62) SAL, 7 Series E38 735iL (M62) SAL, 7 Series E38 740d (M67) SAL, 7 Series E38 740i (M60-2) SAL, 7 Series E38 740i (M62) SAL, 7 Series E38 740iL (M60-2) SAL, 7 Series E38 740iL (M62) SAL, 7 Series E38 750i (M73) SAL, 7 Series E38 750iL (M73) SAL, 7 Series E38 L7 (M73) SAL.
Maintenance
General
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
0 Maintenance And General Data88 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Pre-delivery Check2345
- Lifting Vehicle With A Lifting Platform
- Notes On Using Repair Instructions, Technical Data, Tightening Torques
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Symbols Used And Information In Repair Instructions2
- Air Cleaner: Replacing Air Cleaner Element (shorten Replacement Interval Accordi
- Battery: Check Display (magic Eye); If Necessary, Recharge Battery
- Battery: Checking Acid Level, Topping Up With Distilled Water If Necessary
- Body And Underbody: Checking For Corrosion And Damage
- Body And Underbody: Checking For Corrosion And Damage - Except Cavities
- Brake And Clutch Hydraulic System: Checking Fluid Level, Topping Up If Necessary
- Brake Hydraulics: Checking Fluid Level, Topping Up If Necessary
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- Changing Automatic Transmission Fluid
- Changing Brake Fluid
- Changing Coolant
- Changing Differential Oil
- Changing Engine Oil And Oil Filter
- Checking Clutch Drive Plate For Wear
- Checking Clutch Drive Plate For Wear
- Checking Coolant Level In Event Of Topping Up: Checking Concentration
- Checking Handbrake Lever Travel, Adjusting According To Setting Specifications I
- Checking Horn, Headlight Flashers And Hazard Warning System
- Checking Instrument And Indication Field Lighting
- Checking Instrument And Indication Field Lighting, Heater Blower
- Checking Lighting System
- Checking Roadworthiness
- Checking Steering For Zero Play Steering Tie Rods And Axle Joints, Steering Gear
- Coolant Hoses: Visual Inspection For Leaks
- Diagnostic Brief Test
- Exhaust System: Checking Condition, Mounting And Inspecting For Leaks
- Fault Memory Interrogation
- Front And (if Necessary) Rear Disk Brake Linings: Remove And Install, Check Tota
- Front And Rear Brake Linings: Checking Lining Thickness With Measuring Gauge
- Fuel Lines, Fuel Tank And Fuel Hoses: Visual Inspection For Routing, Condition A
- Heating/air Conditioning: Replacing Microfilter/carbon Canister (shorten Replace
- Heating/air Conditioning: Replacing Recirculated Air Cleaner
- Information/warning Labels23
- Locking Systems: Checking Status And Function, Oiling Or Greasing If Necessary
- Microencapsulated Screws
- Oil Change In Manual Transmission
- Oil Change In Rear Differential
- Output Shafts: Checking Gaiters For Leaks
- Parking Brake: Checking Function, Adjusting/repairing As Prescribed
- Parking Brake: Checking Lining Thickness
- Power Steering/ride-height Control: Visual Inspection For Leaks, Checking Fluid
- Raising BMW Multi-trailer23
- Replacing Spark Plugs
- Resetting Service Interval Indicator According To Factory Specifications2
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear2
- Steering Fluid Reservoir: Checking Fluid Level, Topping Up If Necessary
- Transmission (all Gears): Visual Inspection For Leaks
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Underbody Incl
- Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
- Windscreen Wash/wipe System: Checking Washer Fluid Reservoir And Spray Nozzle Ad
- Windscreen Washer System And Intensive Cleaning System: Checking Fluid Level, To
- BMW Engine Oil Service (M50 / M52 / S50US / S52 / M52TU)2
- Checking/topping Up Oil Level In Rear Differential
- Oil Change In Automatic Transmission (A5S 310Z)2
- Oil Change In Rear Differential Incl2
- Checking/topping Up Fluid Level In Automatic Transmission (A5S 325Z)2
- Checking/topping Up Oil Level In Automatic Transmission (A5S 310Z)
- Notes On Handling Wiring Harnesses And Cables
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
11 Engine (M52TU)164 pages
0 Engine, General17 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- BMW Engine Oil Service (M50 / M52 / S50US / S52 / M52TU)2
- Checking Compression Of All Cylinders (M50 / M52 / S52 / M52TU)2
- Checking Absolute Compression Of All Cylinders
- Removing And Installing Engine (M52 / S52 / M52TU / M54)234
- Engine Identification2345
12 Cylinder Head With Cover15 pages
- Removing And Installing, Sealing Cylinder Head Cover (M52TU / M54 / M56)2
- Removing And Installing/replacing Cylinder Head (M52TU / M54 / M56)234
- Replacing Cylinder Head Gasket (M52 / S52 / M52TU / M54 / M56)
- Disassembling And Assembling Cylinder Head (M52 / S52 / M52TU / M54 / M56)2
- Remachining A Valve Seat (M52 / S52 / M52TU / M54 / M56)
- Checking A Valve Guide For Wear (M52 / S52 / M52TU / M54 / M56)
- Reaming A Valve Guide (M52 / S52 / M52TU / M54 / M56)
- Resurfacing Cylinder Head Sealing Surface (M52 / M52TU / M54 / M56)
- Checking Cylinder Head For Watertightness (M52TU / M54 / M56)2
- 22 Flywheel › Removing And Installing Or Replacing Flywheel (M52 / S52 / M52TU / M54 / S54)2
- 24 Connecting Rod With Bearing › Replacing All Connecting Rod Bearings (M52 / S52 / M52TU / M54 / M56)2
31 Camshaft37 pages
- 36 Variable Camshaft Timing › Removing And Installing Or Replacing Double VANOS Adjustment Unit (M52TU / M542345678910111213
- 40 Oil Supply › Checking Engine Oil Pressure2
- 41 Oil Pump With Filter And Drive › Removing And Installing/replacing Oil Pump (M52TU / M54 / M56)23
- 42 Oil Filter And Lines › Removing And Installing Complete Full-flow Oil Filter (M52 / S52 / M52TU / M542
- 51 Water Pump With Drive › Removing And Installing Complete Water Pump (M52 / S52 / M52TU / M54 / M56)2
- 52 Fan › Removing And Installing/replacing Fan Clutch (S52 / S54 / M52 / M52TU / M54 / M52
- 53 Thermostat And Connections › Removing And Installing/replacing Coolant Thermostat (M52TU / M54 / M56)2
- 61 Intake Manifold › Removing And Installing Intake Air Manifold (M52TU)234
- 62 Exhaust Manifold › Removing And Installing Both Exhaust Manifolds With Catalytic Converters (M52TU23
- 71 Exhaust Gas Recirculation › Removing And Installing Or Replacing EGR Cooler (N47)2
78 Emission Control, Oxygen Sensor4 pages
12 Engine Electrical System (M52TU)55 pages
0 Troubleshooting8 pages
- 12 Ignition Wires, Spark Plugs › Replacing All Spark Plugs
14 Electronic Switching Or Contr.units9 pages
- Replacing Pulse Generator On Crankshaft (M52TU)
- Replacing Pulse Generator On Inlet Camshaft (M52TU / M54 / M56)2
- Replacing Pulse Generator On Exhaust Camshaft (M52TU, M54, M56)
- Replacing Knock Sensor (M52TU, M54, M56)2
- Coding Control Module (DME / DDE)
- Programming Control Unit (DME / DDE)
- Note On Replacing Codable/programmable Control Units
32 Regulator6 pages
41 Starter With Mounting4 pages
- 42 Starter Lead › Replacing Safety Battery Terminal (SBK)2345
61 Oil Pressure-oil Temperature-oil Gauge3 pages
- 63 Switches And Relays › Replacing Temperature Sensor For Electronics
13 Fuel System (M52TU)32 pages
- 0 Checking-setting Engine-emission › Checking Function Of Digital Engine Electronics (DME)
31 Fuel Pump With Drive And Line5 pages
- 41 Speed Governor › Replacing Idle Speed Control Valve (M52TU, M54)23
- 51 Inj.pump, Regulator, Mixt.regulator › Replacing Fuel Pressure Regulator (M52TU)2
53 Injection Nozzle And Lines5 pages
- 54 Throttle And Operation › Removing And Installing/sealing Throttle Assembly (M52TU)234
- 61 Electronic Control Unit › Removing And Installing Or Replacing Air-mass Flow Sensor (M52TU)
- 63 Throttle Potentiometer, Fuel Pump Relay › Replacing Fuel Pump Relay
- 64 Start Valves › Checking Injector Valves For Leaks And Cleaning234
- 90 Carbon Canister Ventilation › Replacing Tank Venting Valve (M52TU, M54)2
16 Fuel Supply System (M52TU)39 pages
12 Fuel Transfer, Sensor For Gauge9 pages
- Removing And Installing / Replacing The Sensor For The Fuel Level Gauge (right)234
- Removing And Installing / Replacing The Sensor For The Fuel Level Gauge (left)23
- Removing And Installing / Replacing Activated-carbon Filter
- Removing And Installing/replacing Activated Carbon Filter With LDP (leak Diagnos
- 13 Fuel Ventilation › Removing And Installing/replacing Activated Carbon Filter With LDP (leak Diagnos
- 14 Fuel Pump › Removing And Installing Or Replacing Fuel Pump2
17 Cooling System (M52TU)37 pages
- 10 Radiator, Expansion Tank, Pipes › Checking Cooling System For Water Leaks2
- 21 Oil Cooler › Flushing Oil Cooler With Lines (automatic Transmission)2345
- 22 Oil Cooler Lines › Flushing Oil Cooler With Lines (automatic Transmission)2345
- 40 Auxiliary Electrical Fan › Removing And Installing/replacing Complete Supplementary Fan (with Fan Cowl)
18 Exhaust System (M52TU)13 pages
24 Automatic Transmission (AUT)113 pages
0 Transmission Assembly47 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Oil Change In Automatic Transmission (A5S 310Z)2
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Adjusting Shift Lever (A5S 310Z: A5S 440Z: A5S 560Z)
- Adjusting Selector Lever (A5S 325Z)
- Removing And Installing Automatic Transmission (A5S 325Z)2345678
- Installing Replacement Transmission (A5S 310Z, A5S 560Z, A5S 440Z)
- Installing Replacement Transmission (A5S 325Z)2
- Dismantling And Assembling Automatic Transmission (A5S560Z)234567891011121314151617181920212223
- Removing And Installing Or Replacing Parking Lock (A5S 325Z)
13 Extension Housing, Bearings, Seal20 pages
- Replacing Radial Seal For Output Flange (A5S 325Z)234
- Removing And Installing Transmission Extension (A5S 325Z)23
- Replacing Output Flange (A5S 310Z)2
- Replacing Output Flange (A5S 560Z)23
- Replacing Bearing On Transmission Extension (A5S 325Z)
- Replacing Bearing On Transmission Extension (A5S 310Z)
- Replacing Bearing On Transmission Extension (A5S 560Z)2
- Replacing Output Flange (A5S 325Z)234
- 15 Electrical Attachments › Removing And Installing/replacing Position Switch (A5S 325Z)2
- 31 Oil Pump › Removing And Installing/replacing Transmission Oil Screen (A5S 325Z)
34 Shift Valves, Parking Lock10 pages
- Removing And Installing/replacing Shift Unit (A5S 325Z)23
- Replacing Solenoid Valve Or Pressure Regulator (A5S 325Z)2
- Replacing Pressure Regulator For System Pressure (AS5 325Z)2
- Replacing Pulse Generator (output Speed) (A5S 325Z)
- Replacing Pulse Generator (turbine Speed) (A5S 325Z)
- Programming/replacing Control Unit
35 Wiring Harness, Shift Elements And Senso2 pages
- 52 Internal Gearshift › Replacing Radial Seal On Manual Shift Valve Shaft (A5S 325Z)23
90 Troubleshooting6 pages
25 Gear Shift Mechanism (AUT) › 16 Centre Shift, Automatic Transmission13 pages
26 Propeller Shaft10 pages
27 Transfer Box › 0 Transfer Case, General3 pages
31 Front Axle47 pages
0 General9 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Layout Of Front Axle Suspension
- Layout Of Spring Strut Shock Absorber
- 10 Front Axle Suspension › Removing And Installing Complete Front Axle (with Spring Strut Shock Absorber)23
- 11 Front Sub-frame › Replacing Front-axle Carrier23
21 Wheel Bearings And Stub Axle5 pages
90 Troubleshooting2 pages
32 Steering And Wheel Alignment100 pages
0 Electronic Chassis Alignment26 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Measuring Ride-level Height Of Vehicle
- General Chassis And Suspension Definitions
- General Information And Definitions2
- Identification Of Sport Suspension
- Identification Of Suspension Without Label
- Information On Replacing Steering Gear After Accident Damage2
- Moving Vehicle Into Design Position
- Moving Vehicle Into Normal Position
- Notes
- Performing Rim Runout Compensation
- Test Conditions For Chassis/wheel Alignment Check
- Troubleshooting After Wheel/chassis Alignment Check On Front Axle/rear Axle23
- Standard Chassis / Wheel Alignment With DIN Load23
- Adjusting Front Wheel Alignment (with KDS)
- Adjusting Rear Axle2
- Carrying Out Steering Angle Sensor Adjustment
- 11 Mechanical Steering Gear › Information On Replacing Steering Gear After Accident Damage2
21 Steering Arms, Tie Rods, Steer. Damper10 pages
31 Steering Column19 pages
- Replacing Upper Section Of Steering Column Trim2
- Removing And Installing / Replacing Lower Section Of Steering Column Trim
- Removing And Installing Or Replacing (lower) Steering Spindle2
- Removing And Installing Or Replacing Steering Angle Sensor
- Removing And Installing Complete Steering Column23
- Replacing Upper Steering Spindle Bearing2
- Replacing Lower Steering Spindle Bearing
- Replacing Adjusting Lever For Steering Column2
- Dismantling And Assembling Complete Steering Column2345
- 33 Steering Wheel › Removing And Installing Steering Wheel23
34 Steering Wheel For Airbag13 pages
- Notes On Scrapping BMW Vehicles With Gas Generators (airbag System)234
- Removing And Installing Or Replacing Airbag Unit
- Replacing Contact Ring (airbag)
- Safety Regulations For Handling Airbag System Components2
- Safety Regulations For Handling Components With Gas Generators2
- Procedure After Airbag Triggering As Result Of An Accident23
41 Pump And Oil Supply12 pages
- Instructions For Removing And Installing Ear Clips2
- Instructions For Using Special Tool 32 4 0002
- Layout Of Power Steering Unit Components And Lines
- Notes On Hydraulic Line With Quick-connect Coupling2
- Servotronic Troubleshooting
- Checking Function Of Power-steering Pump2
- Removing And Installing Power Steering Vane Pump (M52TU / M54)2
- 90 Troubleshooting › Troubleshooting After Wheel/chassis Alignment Check On Front Axle/rear Axle23
33 Rear Axle180 pages
0 General16 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Rear Axle Assembly2
- Rear Differential: Assignment To Model Series
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
11 Final Drive With Cover24 pages
- Rear Differential: Assignment To Model Series
- Replacing Shaft Seal And Input Flange On Final Drive (Type K / M / G)2345
- Replacing Shaft Seal For Input Flange On Final Drive234
- Replacing Drive Flange On Left Or Right Of Final Drive2
- Replacing Shaft Seal For Drive Flange Left Or Right2
- Replacing Rear Cover Gasket On Final Drive
- Replacing Both Bearings On Final Drive Housing (Type M) - Final Drive Removed -23456789
12 Crown Gear And Pinion With Bearings60 pages
- Basic Rules For Setting Contact Pattern - Gleason Gears
- Replacing Bearing For Input Bevel Gear (Type M) - Final Drive Removed -2345678910111213
- Replacing Drive Pinion With Crown Wheel (Type G) - Final Drive Removed -23456789101112
- Replacing Drive Pinion With Crown Wheel (Type K) - Final Drive Removed -2345678910111213141516
- Replacing Input Bevel Gear And Crown Wheel (Type M) - Final Drive Housing Remove23456789101112131415161718
- 13 Differential With Bearings › Replacing Differential Bevel Gears (Type M) - Final Drive Housing Removed -234567
- 17 Final Drive Mounting › Replacing All Rubber Mounts On Front And Rear Final Drive Mounts2
- 31 Rear Sub-frame › Removing And Installing Complete Rear Axle Carrier2
32 Control Arms And Struts12 pages
- Replacing Left Or Right Push Rod/integral Link2
- Removing And Installing Or Replacing Left Or Right Swinging Arm2
- Replacing One Upper Control Arm2
- Replacing One Traction Strut
- Replacing A Ball Joint In Lower Steering Knuckle/wheel Carrier
- Removing And Installing One Steering Knuckle/wheel Carrier23
- Replacing Ball Joint In Lower Steering Knuckle/wheel Carrier (wheel Carrier Remo
- 33 Axle Mounting › Replacing Two Rubber Mounts For Rear Axle Carrier2
52 Shock Absorber8 pages
- Information On Replacing Shock Absorbers
- Arrangement Of Spring Strut Shock Absorber
- Removing And Installing Rear Left Or Right Spring Strut Shock Absorber
- Replacing Rear Left Or Right Spring Strut Shock Absorber
- Replacing Rear Left Or Right Thrust Bearing For Spring Strut / Shock Absorber
- Troubleshooting The Rear Axle And Shock Absorber23
53 Springs With Suspension5 pages
- 55 Stabiliser Bar › Removing And Installing / Replacing Rear Stabilizer
- 90 Troubleshooting › Troubleshooting The Rear Axle And Shock Absorber23
34 Brakes81 pages
0 Brake Testing And Bleeding16 pages
- General Data23
- Checking Brakes On Test Stand
- Checking Thickness Of Brake Lining
- Checking Thickness Of Brake Lining From Model Year '97
- Parking Brake Function Check
- Checking Brake Booster (low-pressure Test)
- Bleeding Brake System With ABS2
- Bleeding Brake System With ABS/ASC-T2
- Bleeding Brake System With DSC3 From 09/97, 750i/iL To 09/982
- Checking Parking Brake Setting (for Inspection)
- Checking Service Brake: High- And Low-pressure Tests
11 Front Brakes11 pages
- Layout Of Fixed Caliper (front)
- Removing And Installing/replacing Brake Linings On Both Front Disk Brakes2
- Removing And Installing/replacing Both Front Brake Disks2
- Removing And Installing Or Replacing Left Or Right Front Brake Caliper2
- Overhauling Left Or Right Front-brake Caliper (brake Caliper Removed)23
- Fine-grinding Both Sides Of Both Front Brake Disks (brake Disks Removed)
21 Rear Brakes11 pages
- Layout Of Floating Caliper (rear)
- Removing And Installing Or Replacing Brake Linings On Both Rear Disk Brakes234
- Removing And Installing Or Replacing Both Rear Brake Disks
- Removing And Installing Or Replacing Left Or Right Rear Brake Caliper2
- Overhauling Left Or Right Rear Brake Caliper (brake Caliper Removed)2
- Fine-grinding Both Sides Of Both Rear Brake Disks (brake Disks Removed)
- 50 Slip Control Systems (ABS, ASC) › Removing And Installing/replacing Transversal-acceleration Sensor DSC3 Up To 09
51 Mechanical-hydraulic Components11 pages
- Removing And Installing / Replacing ABS Hydraulic Control Unit2
- Removing And Installing Or Replacing ABS/ASC-T, DSC1, DSC2, DSC3 Hydraulic Unit23
- Removing And Installing/replacing Hydraulic Unit ABS/ASC-T, DSC3 From 09/982
- Removing And Installing Pre-boost Pump DSC32
- Removing And Installing/replacing DSC3 Precharging Pump (with Charging Piston Un
- Removing And Installing/replacing Pressure Sensor For DSC
52 Electronic Components8 pages
- Replacing Control Unit (for ABS)
- Replacing ABS/ASC-T/DSC Control Module From 09/982
- Replacing Control Module (ASC-T, DSC1, DSC2, DSC3) Up To 09/98
- Removing And Installing / Replacing Front ABS Impulse Sensor
- Removing And Installing/replacing Rear ABS Pulse Generator
- Removing And Installing/replacing Transversal-acceleration Sensor DSC3 Up To 09
- Removing And Installing/replacing Rotation Rate Sensor DSC3 From 09/98
- 90 Troubleshooting › Troubleshooting The Brake System234
35 Pedals21 pages
- 11 Pedal Mounting Block › Removing And Installing Mounting Block For Pedals
- 21 Brake Pedal With Linkage › Removing And Installing Or Replacing Brake Pedal
- 31 Clutch Pedal With Linkage › Removing And Installing / Replacing Clutch Pedal
40 Accelerator Pedal Actuation2 pages
41 Kick-down10 pages
- Removing And Installing/replacing Accelerator Pedal Module
- Replacing Adapter Plate
- Adjusting Bowden Cable For Throttle Valve Actuation
- Removing And Installing Or Replacing Foot Pedal2
- Removing And Installing Or Replacing Accelerator Pedal
- Replacing Bowden Cable For Throttle Valve Actuation23
- Replacing Kick-down Switch
51 Foot-oper. Parking Br. With Conn.comp6 pages
36 Wheels With Tyres24 pages
37 Integrated Suspension Systems19 pages
12 Rear Control And Suspension Elements4 pages
- 15 Electronic Damping Force Adjustment › Removing And Installing/replacing The Control Unit (EDC)
- 90 Troubleshooting › Troubleshooting On Level Control System2
41 Body (SAL)254 pages
0 Body90 pages
- Contents Of Body, General2
- Arrangement Of Shaped Parts On Cavity Sealing2
- Basic Comments On Handling Aluminium Components2
- Bonding Plastic Parts
- Bonding Steel Parts2
- Corrosion Protection2
- Door Joint Sizes/engine Hood And Trunk Lid23
- Embossing Chassis Number
- Frame Alignment Control Dimensions BMW 7 Series E38234567
- General Cementing Instructions
- General Information About Body Repair2
- Gluing Of Body Components
- Grinding Aluminum Parts
- Grinding Steel Parts
- Handling Airbags And Restraint Systems
- Handling Electrical And Electronic Equipment
- Information / Warning Labels
- Information On Hazards
- Information On Vehicle Protection
- Installation Of A Cavity Seal With Cavity Foam2
- Installation Of A Cavity Seal With Cavity Foam2
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
- Installing Cavity Bulkhead Cover For Side Member23
- Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
- Materials Science23
- Notes On Repairs Of Aluminium Parts2
- Opening Adhesive Bonds
- Opening Weld Joints
- Quality Standard
- Recommended Working Methods And Tools2
- Removal Of PVC Material In Repair Area
- Riveting Aluminium Parts2
- Riveting Steel Parts
- Safety At Work2
- Spot-weld Bonding Steel Parts
- Straightening Aluminium Parts2
- Straightening Steel Parts2
- Use Of Materials In Outer Shell2
- Vehicle Identification Number, General
- Welding And Soldering Steel Parts23
- Welding In Reinforcement Plate (steel Plate)2
- Welding Of Galvanized Plates
- Window And Door Seams2
- Workshop Equipment2
- Replacing Unfinished Body Shell
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- Notes On Cavity Foam2
- General Instructions On Painting
11 Support Members33 pages
- Installing Cavity Bulkhead Cover For Side Member23
- Replacing Front Section Of Engine Support To Left Wheel Arch2345678910
- Replacing Right Engine Carrier (partial Replacement In Front Of Front Axle)23
- Replacing Front Section Of Left Engine Support2345678
- Replacing Left Or Right Side Member Cover (partial Replacement Of A-column And R23456789
- 12 Luggage Compartment Floor › Replacing Complete Rear Trunk Floor (rear Left Side Panel And Tail Panel Removed234
14 Wheel Wells29 pages
- Installation Of A Cavity Seal With Cavity Foam2
- Installing Shaped Parts For Cavity Bulkheads, Except For Cover For Side Member234
- Vehicle Identification Number, General
- Replacing Front Left Wheel Arch23456
- Replacing Outer Section Of Left Or Right Rear Wheel Housing (side Panel Removed)234567
- Replacing Complete Rear Left Wheel Arch23456789
- 33 Front Trim Panel › Replacing Front Wall234
- 34 Rear Trim Panel › Replacing Outer Section Of Rear Apron (partial Replacement)2345
35 Side Panels20 pages
61 Front Lid9 pages
51 Body Equipment (SAL)238 pages
11 Front Bumper14 pages
- Repair Solution For Replacing Lateral Insert On Bumper
- Removing And Installing Complete Front Bumper2
- Replacing Front Bumper2345
- Replacing Front Center Section (carrier) Of Bumper
- Replacing Front Bumper Trim
- Replacing Baseplate For Licence Plate
- Replacing Body Molding For Left Or Right Bumper
- Replacing Left Or Right Bracket For Front Bumper
- Replacing One Impact Absorber For Front Bumper
12 Rear Bumper9 pages
- 14 BMW Emblems, Model Emblems › Removing And Installing / Replacing Rear Model Emblem
16 Mirrors-covers-ashtrays-shelves-trays46 pages
- Cementing Of Mirror Base2
- Outside Survey Mirror Can Be Folded In
- Removing And Installing/replacing Wooden Finisher And Front Section On Cup Holde234
- Replacing Left Or Right Outside Mirror Housing
- Removing And Installing Mirror On Left Or Right Front Door
- Replacing Mirror Glass2
- Removing And Installing/replacing Interior Rearview Mirror (overview)2
- Removing And Installing/replacing Interior Rearview Mirror (with /X: Cable And P2
- Removing And Installing/replacing Interior Rearview Mirror (with Full Foot)
- Removing And Installing/replacing Interior Rearview Mirror (with Mirror Arm End23
- Removing And Installing/replacing Interior Rearview Mirror (with Rain Sensor)23
- Removing And Installing / Replacing Interior Rearview Mirror (with Remote Contro
- Removing And Installing Or Replacing Sun Visor And Left Or Right Counter Support
- Removing And Installing Center Console2345
- Replacing Oddments Tray2
- Removing And Installing/replacing Front Cup Holder23
- Removing And Installing/replacing Rear Can Holder
- Removing And Installing / Replacing Finisher For Preselector Lever
- Replacing Wooden Finishers For Storage Tray (centre Console)234
- Removing And Installing Right Glove Box2
- Removing And Installing / Removing Sun Roller Blind From Fixed Side Window On Le
- Removing And Installing Or Replacing Blind At Side Window Of Left Or Right Rear
- Removing And Installing/replacing Rear Left/right Grab Handle
- Removing And Installing Or Replacing Front Grab Handle
- 17 Lids › Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
21 Front Door Locks, Handles, Fittings16 pages
- Adjusting Front Left Or Right Door Detent (lock Wedge)
- Removing And Installing / Replacing Door Lock On Left Or Right Front Door2345
- Removing And Installing Or Replacing Lock On Left Or Right Front Door
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo23
- Removing And Installing Or Replacing Inside Door Opener In Left Or Right Front D
- Removing And Installing Or Replacing Window Recess Cover Strip On Outside Of Lef
- Removing And Installing Or Replacing Chrome Strip From Left Or Right Window Rece
- Replacing Window Recess Cover On Left Or Right Front Door
- Replacing Bulb For Outside Door Handle Light, Front Left Or Right
- Replacing Bulb For Inside Door Handle Light, Front Left Or Right
22 Rear Door Locks, Handles, Fittings8 pages
- Adjusting Rear Left Or Right Door Detent (lock Wedges)
- Removing And Installing / Replacing Outside Handle On Left Or Right Back Door23
- Removing And Installing/replacing Inside Door Opener Of Rear Left Or Right Door
- Removing And Installing/replacing Window Cavity Cover Strip On Rear Door On Left
- Replacing Bulb For Outside Door Handle Light, Rear Left Or Right
- Replacing Bulb For Inside Door Handle Light, Rear Left Or Right
24 Trunk Latch, Locks15 pages
- Information On Automatic Trunk Lid Controls (electrohydraulic)23
- Adjusting Trunk Lid Lock (upper/lower Section Of Trunk Lid Lock)
- Removing And Installing/replacing Lock (locking Cylinder) For Trunk Lid Set2
- Removing And Installing/replacing Trunk Lid Lock (upper Section Of Trunk Lid Loc2
- Removing And Installing/replacing Hydraulic Control Unit For Operating Trunk Lid23
- Removing And Installing/replacing Hydraulic Cylinder For Trunk Lid (electrohydra2
- Removing And Installing Or Replacing Left Or Right Gas Strut For Trunk Lid
- Replacing Rubber Mount On Rear Lid Lid Support
31 Front And Rear Window39 pages
- Instructions On Gluing Windscreen23456789
- Removing Windscreen With /Roll Out 20002345
- Removing And Installing Front Windscreen234567891011
- Replacing Windscreen (complete Windscreen)
- Repairing Damage To Windscreens Caused By Pitting (stone Chips) (clear And Tinte
- Removing And Installing Or Replacing Left Or Right Gutter Along Windshield
- Removing And Installing Rear Window23456789
- Replacing Rear Window (rear Window Broken)
- Replacing Rear Window (complete Rear Window)
32 Front Manually Operated Windows3 pages
- 33 Front Electrically Operated Windows › Removing And Installing Electric Window Regulator In Left Or Right Front Door23
34 Rear Manually Operated Windows9 pages
- 35 Rear Electrically Operated Windows › Removing And Installing Complete Electrical Window Regulator From Rear Left And
- 37 Electrical Power Windows, Body › Removing And Installing Complete Electrical Window Regulator From Rear Left And
42 Rear Door Trim Panel With Arm Rest8 pages
43 Side Covering With Armrests8 pages
- Removing And Installing Or Replacing Trim On Left Or Right Door Pillar (top)2
- Removing And Installing Or Replacing Trim For Left Or Right Door Pillar (bottom)2
- Removing And Installing Or Replacing Trim For Front Left Or Right Roof Pillar2
- Removing And Installing Or Replacing Trim From Rear Left Or Right Roof Pillar2
- 45 Instrument Cluster Trim Panel › Removing And Installing Dashboard Trim Panel2345
46 Parcel Shelf Trim Pan.-roller Sun Blind11 pages
- Removing And Installing/replacing Trim For Rear Parcel Shelf23
- Removing And Installing Trim For Oddments Tray (back Shelf With Rear Window Roll
- Replacing Trim For Oddments Tray (back Shelf With Rear Window Roller Blind)
- Removing And Installing Trim For Oddments Tray (back Shelf With Electric Rear Se
- Replacing Trim For Oddments Tray (back Shelf With Rear Window Roller Blind And E
- Removing And Installing Trim For Oddments Tray (back Shelf With Rear Window Roll
- Removing And Installing/replacing Rear Window Roller Blind
- Removing And Installing/replacing Rear Window Roller Blind (with Electric Rear S
- 9 Replacing Finisher For Top Of Rear Apron
47 Floor-lugg.comp.-eng.comp.tr.panels7 pages
- Romoving And Installing / Replacing The Front (inside) Left Or Right Rocker Pane
- Removing And Installing/replacing The Rear (inside) Left Or Right Rocker Panel S
- Removing And Installing/replacing Luggage Compartment Floor Trim Panel
- Removing And Installing/replacing Trunk Wheel Housing Trim, Left2
- Removing And Installing/replacing Flap In Luggage Compartment Trim, Left Or Righ2
- 49 Rear Lid Trim Panel › Removing And Installing Or Replacing Trim For Trunk Lid2
52 Seats100 pages
13 Front Seat, Normal, Manual32 pages
- Removing And Installing Left Or Right Front Seat (normal / Manual)23
- Removing And Installing / Replacing Both Seat Rails On Left Or Right Front Seat23
- Adjusting Bowden Cable For Longitudinal Adjustment Of Left Or Right Front Seat (
- Replacing Bowden Cable For Longitudinal Adjustment On Left Or Right Front Seat (
- Removing And Installing / Replacing Controls On Left / Right Front Seat (normal2
- Removing And Installing / Replacing Seat Frame On Left/right Front Seat (normal2
- Removing And Installing / Replacing Backrest Frame On Left Or Right Front Seat (
- Removing And Installing / Replacing Outer Cover On Left Or Right Front Seat Back2
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Replacing Left Or Right Lumbar Supports On Front Seat (normal: Manual)2
- Removing And Installing / Replacing Rear Panel On Left Or Right Front Seat Backr
- Removing And Installing / Replacing Front Headrest (normal: Manual)
- Replacing Seat Cover On Left Or Right Front Seat (normal: Manual)234
- Replacing Backrest Cover For Front Seat (normal/manual), Left Or Right2345
- Replacing Left Or Right Support For Front Seat (normal / Manual)
- Replacing Left Or Right Support For Front Seat Back-rest (normal / Manual)
- Removing And Installing/replacing Valve Housing For From Left Or Right Lumbar Su
14 Front Seat, Normal, Electric7 pages
- Removing And Installing Left Or Right Front Seat (normal / Electric)23
- Removing And Installing/replacing Head Restraint Support On Front Seat (normal/e
- Removing And Installing Or Replacing Front Left Or Right Head Restraints (standa
- Additional Work (normal: Electric) With Defective Drive For Longitudinal Adjustm2
16 Front Seat, Sports, Electric2 pages
17 Front Seat, Comfort39 pages
- Removing And Installing Front Seat (comfort)
- Removing And Installing Or Replacing Both Seat Rails On Left Or Right Front Seat23
- Removing And Installing / Replacing Seat Frame On Left Or Right Front Seat (comf
- Removing And Installing/replacing Drive For Active Seat, Left Or Right2345
- Removing And Installing / Replacing Backrest Frame On Left Or Right Front Seat (
- Removing And Installing / Replacing Cover On Left Or Right Front Seat (comfort)2
- Removing And Installing / Replacing Inside Cover From Left Or Right Front Seat (
- Replacing Lumbar Support Cushion On Left Or Right Front Seat (comfort)2
- Removing And Installing/replacing Top Rear Panel On Front Seat Backrest (luxury2
- Removing And Installing/replacing Top Rear Panel On Front Seat Backrest (luxury23456
- Removing And Installing/replacing Bottom Rear Panel On Front Seat Backrest (luxu
- Removing And Installing/replacing Rear Panel On Front Seat Backrest (luxury Seat
- Removing And Installing / Replacing Headrest Support On Left Or Right Front Seat2
- Removing And Installing Or Replacing Front Left Or Right Head Restraints (comfor
- Replacing Seat Cover On Left Or Right Front Seat (comfort)23
- Replacing Back-rest Cover For Front Seat (comfort) On Left Or Right Sides2345
- Replacing Padding For Left Or Right Front Seat (comfort Seat)
- Replacing Support For Left Or Right Front Seat Backrest (comfort)
25 Rear Seat, Normal, Electric14 pages
- Removing And Installing / Replacing Rear Seat (normal: Electric)
- Removing And Installing / Replacing Left Or Right Side Section Of Rear Seat Back
- Removing And Installing / Replacing Backrest For Rear Seat (normal: Electric)2
- Removing And Installing / Replacing Headrest Support (normal / Electric) At Rear
- Removing And Installing / Replacing Rear Left Or Right Headrest (normal: Electri
- Replacing Back-rest Cover For Left Or Right Rear Seat (normal/electric)2
- Removing And Installing / Replacing Backrest Frame From Left Or Right Rear Seat2
- Removing And Installing / Replacing Transmission For Rear Seat Backrest (normal2
- Replacing Lumbar Support Cushion On Left Or Right Rear Seat (normal: Electric)
- Removing And Installing / Replacing Valve Housing On Lumbar Support For Rear Sea
- 26 Rear Seat, Through-loading › Replacing Seat Cover For Rear Seat (through-loading System)
54 Slide-tilt Sunroof And Convertible Top (SAL)65 pages
- 10 Sunroof › Repair Instructions For Bonded Seals23
12 Mechanical Sun Roof Components59 pages
- Notes On Steel And Glass Slide/tilt Sunroofs (initialization/normalization/learn23
- Removing And Installing / Replacing Bearing For Wind Deflector, Left Or Right
- Removing And Installing / Replacing Float Switch For Left Or Right Gutter On Gla
- Replacing Stop On Headliner For Glass Sliding/tilting Sunroof Lid On Left Or Rig2
- Adjusting Glass Sliding/tilting Sunroof Lid23
- Adjusting Sun Roof23
- Replacing Bellows For Glass Sliding/tilting Sunroof, Left Or Right
- Removing And Installing Sun Roof Lid234
- Removing And Installing Glass Sliding/tilting Sunroof Lid234
- Replacing Glass Sliding/tilting Sunroof Lid
- Replacing Seal For Glass Sliding/tilting Sunroof Lid
- Replacing Seal For Slide/tilt Sunroof Lid
- Removing And Installing / Replacing Roof Lining Frame Mechanism For Glass Slidin23
- Replacing Arm (positioner) For Sunroof Lid2
- Removing And Installing/replacing Headliner For Sun-roof Lid2
- Removing And Installing Or Replacing Gutter Strip
- Removing And Installing/replacing Roof-lining Frame For Glass Sliding/tilting Su2
- Removing And Installing / Replacing Water Channel For Glass Sliding/tilting Sunr
- Removing And Installing Complete Sliding/tilting Sunroof (frame)2
- Removing And Installing Complete Glass Sliding/tilting Sunroof
- Replacing Control Rail For Glass Sliding/tilting Sunroof, Left Or Right234567
- Removing And Installing Both Drive Cables For Glass Sliding/tilting Sunroof Actu2345678
- Adjusting Both Drive Cables For Glass Sliding/tilting Sunroof Actuation
- Removing And Installing / Replacing Wind Deflector
- Removing And Installing / Replacing Wind Deflector For Glass Sliding/tilting Sun
- Replacing Sliding/tilting Sunroof Frame
- Replacing Glass Sliding/tilting Sunroof Frame
- 13 Electrical Sun Roof Components › Notes On Steel And Glass Slide/tilt Sunroofs (initialization/normalization/learn23
61 General Electrical System166 pages
0 Troubleshooting15 pages
- Instructions On Starting Aid
- Battery
- Notes For Cars With Twin-battery System2
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Treating Cables And Fibre-optic Cables
13 Plug Connection, Terminal, Fuse Box60 pages
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Butt Connector For Repairing A Plug Connection234
- Crimping Stop Parts234
- DME Master Relay Connector
- Installing Fan Connector For Retrofitting/repairs2345
- Special Tools For Wiring Harness Repairs23
- Unlocking And Disconnecting Different Plug Connections23
- Antenna Elbow Plug On Radio Receiver23
- Base Of Tab Connector Housings
- Crimping Micro Power Quadlock Contacts (MPQ)
- Crimping Micro Quadlock System Contacts (MQS)2
- Crimping Annular Contacts
- Crimping Optical Fibres2
- Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
- Cutting To Length And Stripping Insulation From Cables
- Front Left Wiring Harness Repair23
- In-line Plugs, 30-pin, Hybrid System MQS/MPQ2
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Relay Carrier
- Repairing Front Right Wiring Harness2345678
- Repairing Ribbon Cables
- Retaining Bracket
- Socket Housing (radio Plug), Hybrid System MQS/MPQ23
- Treating Cables And Fibre-optic Cables
20 Battery17 pages
- Instructions For Disconnecting And Connecting Battery23
- Instructions On Starting Aid
- Battery
- Notes For Cars With Twin-battery System2
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
- AGM Battery234
- Battery Charging
- Battery Open-circuit Current Test
- 21 Battery-vapour Separator › Removing And Installing Battery2
31 Switch27 pages
- Removing And Installing/replacing Inclination Switch For Automatic Trunk Lid Act
- Removing And Installing/replacing Fixture For Steering Column Stalk23
- Removing And Installing/replacing Turn Indicator/headlight Dip Lever
- Removing And Installing The Ignition Switch
- Removing And Installing/replacing Steering Column Adjustment Lever2
- Removing And Installing/replacing Windshield Wiper Lever
- Removing And Installing Switch Unit In Center Console
- Replacing Switch Unit In Center Console
- Removing And Installing / Replacing Switch From Hazard Warning Lights
- Removing And Installing / Replacing Switch For Central Locking System
- Removing And Installing/replacing Switch For Automatic Trunk Lid Actuation
- Removing And Installing / Replacing Switch For Left Or Right Seat Heating
- Replacing Rocker Switch For Side-window Operation
- Replacing Switch Combination For Seat Adjustment
- Removing And Installing/replacing Switch For Front Lumbar Support
- Removing And Installing / Replacing Switch For Automatic Stability Control
- Removing And Installing / Replacing Switch For Electronic Damper Control
- Removing And Installing / Replacing Switch For Rear Window Roller Blind
- Removing And Installing / Replacing Switch For Park Distance Control
- Replacing Switch On Impact Cushion For Left Or Right Airbag
- Replacing Switch On Sports Steering Wheel On Left Or Right
- Replacing Brake-light Switch2
- Carrying Out Steering Angle Sensor Adjustment
35 ECUs, Modules16 pages
- Control Units, Switches, Relays
- Note On Replacing Codable/programmable Control Units
- Notes On ESD Protection (Electro Static Discharge)23
- Removing And Installing/replacing Rain Sensor
- Removing And Installing/replacing Control Unit For Active Seat
- Removing And Installing Or Replacing Door Module
- Initializing Rain Sensor
- Removing And Installing / Replacing Control Unit For Rear Window Sun Roller Blin
- Removing And Installing Or Replacing Sunroof Module
- Removing And Installing/replacing Ringantenna Of Electronic Immobiliser2
- Replacing Control Unit For Left Xenon Headlight
- Replacing Control Unit For Right Xenon Headlight
- Vehicle Programming And Coding
36 Relays2 pages
- 67 Headlight Washer System › Adjusting Spray Nozzles For Headlight-cleaning System
- 71 Window Washer System › Adjusting Windshield Washer Spray Nozzles2
62 Instruments3 pages
63 Lights47 pages
12 Headlights16 pages
- Removing And Installing/replacing Complete Left-hand Headlight Assembly2
- Removing And Installing Or Replacing Complete Right Headlight2
- Removing And Installing Or Replacing Lens/reflector For Left Headlight
- Removing And Installing Or Replacing Lens/reflector For Right Headlight
- Removing And Installing Or Replacing Lens With Cover Frame For Left Headlight
- Removing And Installing Or Replacing Lens With Cover Frame For Right Headlight
- Replacing Left Headlight Insert
- Replacing Right Headlight Insert
- Replacing Control Unit For Left Xenon Headlight
- Replacing Control Unit For Right Xenon Headlight
- Replacing Ignition Unit For Left Xenon Headlight
- Replacing Right Ignition Unit For Right Xenon Headlight
- Removing And Installing Or Replacing Headlight Vertical Aim Adjuster
- Removing And Installing Or Replacing Right Headlight Vertical Aim Adjuster
- 13 Turn Signal Indicator Lights › Removing And Installing/replacing Complete Front Left Or Right Turn Signal Lamp
- 17 Fog Lights, Auxiliary Lights › Removing And Installing Or Replacing Fog Lamp Insert (complete)
- 21 Rear Light Cluster › Removing And Installing Or Replacing Complete Tail Light Assembly
99 Light Bulbs19 pages
- Instructions For Handling Light Bulbs (exterior Lights)
- Instructions For Replacing Light Bulbs (interior Lights)
- Replacing Bulb For Refrigerator
- Replacing Halogen Light Bulb For Left Or Right High-beam Headlight
- Replacing Halogen Light Bulb For Left Or Right High-beam Headlight
- Replacing Lamp For Left Xenon Light
- Replacing Right Lamp For Xenon Light
- Replacing Bulb For Left Or Right Front Parking Light
- Replacing Halogen Bulb For Left Or Right Front Fog Lamp
- Replacing Bulb For Left Or Right Front Turn Indicator
- Replacing Bulb For Left Or Right Tail Light Assembly
- Replacing Bulb For Left Or Right License-plate Light
- Replacing Light Bulb(s) For Ceiling Light2
- Replacing Bulb(s) For Mirror Light
- Replacing Bulb For Outside Door Handle Light, Front Left Or Right
- Replacing Bulb For Inside Door Handle Light, Front Left Or Right
- Replacing Bulb For Outside Door Handle Light, Rear Left Or Right
- Replacing Bulb For Inside Door Handle Light, Rear Left Or Right
64 Heating And Air Conditioning125 pages
11 Heater With Operation30 pages
- Installing Servodrive
- Removing And Installing Or Replacing Heater
- Replacing Heater Core (air Conditioner Control)2
- Replacing Heater Core (air Conditioner Control)234
- Removing And Installing Or Replacing Fan For Heater And Air Conditioner (air Con
- Removing And Installing Or Replacing Blower For Heater And Air Conditioner (auto2
- Removing And Installing Or Replacing Switch For Blower On Air Conditioner
- Removing And Installing/replacing Auxiliary Water Pump (on Fan Cowl)
- Replacing Water Valve For Heater234
- Replacing Front Plate (air Conditioner Control)
- Replacing Front Plate (air Conditioner Controls)
- Removing And Installing Or Replacing Pushbutton Caps From Heater Controls (air C
- Replacing Baseplate For Heater Controls
- Removing And Installing Or Replacing Regulator For Heater Blower
- Removing And Installing Heater Control
- Removing And Installing / Replacing The Rear Fan Completely23
- Removing And Installing / Replacing The Rear Fan
- Removing And Installing / Replacing The Controller For The Rear Fan
- Removing And Installing The Heater Actuater For The Rear Fan Completely
- Replacing The Heater Actuater For The Rear Fan
12 Auxil. Heater With Control Elements21 pages
- Bleeding Independant Heating (Thermo Top S)2
- Checking Function Of Independant Heating (Thermo Top S)
- Removing And Installing Complete Heater (Thermo Top Z/C)2
- Replacing Complete Heater (Thermo Top Z/C)
- Removing And Installing / Replacing Complete Heater (Thermo Top S)2
- Removing And Installing / Replacing Glow Element (Thermo Top S)2
- Removing And Installing / Replacing Flame Detector (Thermo Top S)
- Removing And Installing / Replacing Control Unit With Heat Exchanger (Thermo Top2
- Removing And Installing / Replacing Combustion Air Blower (Thermo Top S)
- Removing And Installing / Replacing Burner Insert (Thermo Top S)
- Removing And Installing / Replacing Circulation Pump (Thermo Top S)
- Removing And Installing Or Replacing Muffler
- Removing And Installing Or Replacing Fuel Pump
- Removing And Installing / Replacing Receiver/Telestart Of Independent Heating2
- Overview Of Defects For Independent Heating Thermo Top S
22 Nozzles And Outlets11 pages
- Removing And Installing / Replacing Left Fresh-air Grill2
- Removing And Installing / Replacing Right Fresh-air Grill2
- Removing And Installing / Replacing Center Fresh-air Grill (air Conditioner Cont23
- Removing And Installing / Replacing Center Fresh-air Grill (climate Control)23
- Removing And Installing / Replacing Fresh-air Grill In Rear Of Car
50 Air Conditioning System19 pages
- Air Conditioner Test (R 134a)
- Instructions For Handling Refrigerant R 134a
- Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
- Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
- Leak-testing With Leak Tester Device2
- Safety Instructions For Handling Refrigerant R134a
- Safety Instructions For Handling Refrigerant Oil2
- Troubleshooting By Pressure Measurement (R 134a)23
- Drawing Off, Evacuating And Filling A/C System (R 134a)2
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
51 AC Housing-evaporator, Switching Elemts10 pages
- Removing And Installing / Replacing Expansion Valve (air Conditioner Control)23
- Removing And Installing / Replacing Expansion Valve (air-conditioning)2
- Removing And Installing / Replacing Expansion Valve (automatic Air Conditioner)2
- Removing And Installing / Replacing Evaporator (air Conditioner Control)
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
53 Condenser And Dryer With Lines8 pages
- Removing And Installing Cassette (condenser For Air Conditioner)23
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
- Notes On Replacing Drier Bottle Or Drier Insert
- Removing And Installing / Replacing Drier Flask For Air Conditioner
- Removing And Installing Or Replacing Condenser For Air Conditioner
99 Troubleshooting14 pages
- Fault 01 Combustion Air Blower
- Fault 02 Flame Detector
- Fault 03 Glow Plug
- Fault 04 Circulation Pump
- Fault 05 Temperature Sensor
- Fault 06 Park Heating Metering Pump
- Fault 07 Overheating Protection
- Fault 08 Burner Insert
- Fault 1
- Fault 4
- Fault 6
- Fault 6
- Overview Of Defects For Independent Heating Thermo Top S
- Reading Out Flashcode
65 Audio, Navigation And Information System44 pages
- 20 Aerial-antenna › Antenna Elbow Plug On Radio Receiver23
- 24 Rear Window Aerial-antenna › Removing And Installing Or Replacing Antenna Amplifier
- 50 Video And TV Equipment › Removing And Installing/replacing Video Module For On-board Monitor (saloon)
52 Video Monitor11 pages
- Removing And Installing/replacing Cassette Drive2
- Removing And Installing Complete On-board Monitor (widescreen)
- Replacing Panel For On-board Monitor (control Panel, Widescreen)2
- Removing And Installing/replacing Housing With Drive For On-board Monitor (wides
- Removing And Installing On-board Monitor2
- Replacing Trim Panel For On-board Monitor (control Panel)
- Removing And Installing/replacing LC Display For On-board Monitor2
- 75 Anti-theft Alarm System › Removing And Installing/replacing Control Unit For Radio Interior Protection
77 Airbag Trigger Device, Diagnosis Unit5 pages
- 81 On-board Computer › Removing And Installing Or Replacing Multi-Information-Display (MID)
- 83 Car Communication Computer (CCC) › Removing And Installing/replacing Cassette Drive2
90 Navigation Systems9 pages
- Notes On Handling Navigation Computers
- Calibrating Wheels For Navigation System 1 (up To 9/97, Measured With Distance T
- Removing And Installing/replacing Navigation Computer With CD-drive
- Removing And Installing/replacing Receiver Module For Global Positioning System
- Removing And Installing Magnetic Field Sensor
- Removing And Installing/replacing Antenna For Global Positioning System (GPS)
- Replacing CD/DVD Drive For Navigation Computer23
66 Distance Systems, Cruise Control5 pages
12 Radio-controlled Locking System2 pages
- 20 Park Distance Control › Removing And Installing / Replacing A Rear Ultrasonic Converter (center)
31 Adaptive Cruise Control2 pages
67 Electrical Drives18 pages
- 32 Drive, Heating-ventilation-air Con › Removing And Installing Or Replacing Sensor Blower On Heating Controls
- 52 Transmission On Wiper System › Removing And Installing Or Replacing Contact Pressure Adjuster
- 61 Drive, Slide-tilt Sunroof-conv. Top › Removing And Installing Or Replacing Drive With Gear For Actuating Slide/tilt Su2
- 63 Drive Unit, Headlight Wipe-wash Unit › Removing And Installing Or Replacing Windshield Wiper Motor
- 65 Drive, Sun Roller Blind-sun Visor › Removing And Installing Or Replacing Drive For Sun Roller Blind23
72 Parts - Accessories (Body)68 pages
12 Airbag Generator-airbag Unit For Pass51 pages
- Repairing Airbag Cables2
- Safety Precautions And General Information
- Safety Regulations For Handling Airbag System Components2
- Safety Regulations For Handling Components With Gas Generators2
- Airbag System
- Deactivation Of Airbags234
- Procedure After Airbag Triggering As Result Of An Accident23
- Safety Regulations For Handling Airbag Modules, Airbag Components And Pyrotechni
- Scrapping Vehicles With Passenger Airbag And Pyrotechnic Belt Tensioners
- Unlocking/locking Airbag Plug Connections234
- Removing And Installing Or Replacing Airbag Module On Passenger Side2345
- Removing And Installing/replacing Airbag Module On Left Or Right Front Door23
- Removing And Installing/replacing Airbag Module On Left Or Right Rear Door2
- Removing And Installing / Replacing Left Or Right ITS Head Airbag (model Without23456789101112131415
- Removing And Installing Left Or Right ITS Head Airbag (model Fitted With Sliding
- Removing And Installing/replacing Left Or Right Head Airbag In Rear Compartment23
- Removing And Installing/replacing Left Or Right Head Airbag In Rear Compartment
84 Communication Systems9 pages
11 Transceiver, Handset-support, Card Reade7 pages
- Removing And Installing / Replacing Eject Box2
- Removing And Installing/replacing Transceiver
- Removing And Installing/replacing Interface For D-Network Car Phone
- Replacing Cordless Keypad Handset
- Removing And Installing/replacing Line Compensator (cellular Phone)
- Removing And Installing/replacing Hands-free Charging Electronics
86 Trailers107 pages
10 Loading Platform71 pages
- Body And Underbody: Checking For Corrosion And Damage
- Raising BMW Multi-trailer23
- Adjusting Brake System23
- Adjusting Spring Force Accumulator
- Disassembly Of Camlock Retaining Cam
- Disassembly Of Base Plate
- Disassembly Of Bracket On Platform Base
- Disassembly Of Front Apron
- Disassembly Of Front Protection Bar
- Disassembly Of Jockey Wheel Or Jockey Wheel Mount
- Disassembly Of Left And Right Aprons
- Disassembly Of Left And Right Lamp Housings
- Disassembly Of Left And Right Wheel Boxes
- Disassembly Of Licence Plate Mounting Plate
- Disassembly Of Loading Ramp Frame/disassembly Of Rail, Left/right
- Disassembly Of Rear Apron
- Disconnecting Plug Connection, Wiring Harness, Front/rear
- Installation Position Of BMW Lettering
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Removing Camlock Retaining Cam On Loading Ramp
- Removing Camlock Screw Cap
- Removing And Installing Or Replacing Left Or Right Coil Spring2
- Removing Bolt On Loading Ramp
- Removing Brake Shoes2345
- Removing Entry Profile Section On Loading Ramp, Left, Right And Center
- Removing Left Or Right Shock Absorber
- Removing Loading Ramp Lock2
- Removing Mounting Bracket Sealing Cap
- Removing Mounting Bracket, Center, Left And Right
- Removing Outer Pull Rod Mount, Left And Right
- Removing Overrunning Equipment/maintaining Or Replacing Guide Bush/installing Ov2345
- Removing Plastic Bush/metal Bush
- Removing Rear Supports And Bracket
- Removing Reflecting Rear Light
- Removing Rest On Loading Ramp, Left, Right And Center
- Removing Shock Absorber From Overrunning Equipment
- Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
- Removing Wheel Bearing2
- Removing Wooden Rest On Loading Ramp, Left, Right And Center
- Repair Work On GFP Components With Gelcoat Surface
- Replacing 12 Volt Socket2
- Replacing Bar
- Replacing Drawbar Members, Left And Right2
- Replacing Gaiter
- Replacing Holder For Chock
- Replacing Lashing Plate And Lashing Eye
- Replacing License Plate Light
- Replacing Position Light
- Replacing Rear Light
- Troubleshooting On Multi-trailer2
21 Hood36 pages
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Adjusting Hood Pretension - Camloc Fastener With Spacers23
- Adjusting Rear Lid To Fit2
- Adjusting Rotary Striker Lock
- Adjusting Side Lid To Fit2
- Attaching/replacing BMW Badge2
- Fitting BMW Logo
- Installing Hood Seal
- Installing Rubber Roof Strip
- Installing Seal For Rear Lid And Side Lid
- Installing Sponge Rubber Seal
- Removing Ball Pivot
- Removing Centering Pin From Mounting Bracket
- Removing Gas Spring
- Removing Gas Spring Retaining Bracket
- Removing Hinge Bracket On Rear Lid
- Removing Lid
- Removing Lock Barrel
- Removing Lock Striker Fixture On Rear Lid
- Removing Plug For Inside Light2
- Removing Roof Railing
- Removing Roof Railing Adapter2
- Removing Rotary Striker Lock2
- Removing Side Lid Hinge
- Replacing Inside Light
- Replacing Inside Light Power Cable2
99 Paintwork2 pages