Mini Ram Van L4-156 2.6L SOHC VIN G 2-bbl (1984)
Headliner: Customer Interest
Headliner - Sagging at Rear
Models
1984 Ram Van, Caravan & Voyager
Subject
Headliner Sagging
Index
BODY
Date February 7, 1984
No.
23-09-84
P-788
SYMPTOM/CONDITION
The full headliner panel on some subject vehicles may exhibit a sag in the center area at the rear of the domelight. To correct this condition use the
following procedure.
PARTS REQUIRED
1 - H452AA3 - Silver
1 - H452BL3 - Beige
1 - H452BB5 - Blue
1 - H452CK5 - Saddle
1 - H452TM6 - Red
REPAIR PROCEDURE
1.
Remove the domelight lens and housing located behind driver and passenger seat.
FIGURE 1
2.
Measure 13-1/2" back from the domelight retainer's rear edge in the center (side to side) of the headliner panel (Figure 1).
3.
Carefully cut a 1/4" diameter hole in the headliner. A 1/4" diameter hole is in the sheetmetal roof bow that will accept the push-type fastener listed
above. This same fastener is used at the liftgate opening in the panel.
4.
Install fastener and secure by pushing pin through the center of the fastener head until flush.
5.
Install domelight housing and lens.
POLICY:
Reimbursable within the provisions of the warranty