ford Workshop Repair Guides

Ford Workshop Service and Repair Manuals

ABOUT US
Power Steering Pump to Steering Gear Pressure Line - 2.4L Duratorq-TDCi (Puma) Diesel-3.2L Duratorq-TDCi (Puma) Diesel > < Power Steering Pump - 2.3L Duratec-HE (MI4)

Transit 2006.5 (04.2006-)

Power Steering - Power Steering Pump to Steering Gear Pressure Line—2.4L Duratorq-TDCi (Puma) Diesel Transit 2006.5 (04/2006-)
Removal and Installation

Removal
  1. Slide open the bolt cover.

  1. Remove the accessory drive belt shield retaining bolts.

  1. Detach the fuel charging wiring harness and remove the accessory drive belt shield.

  1. Disconnect the power steering line from the power steering pump.
    1. Remove the bolt.
    1. Disconnect the union.
    • Allow the fluid to drain into a suitable container.
  1. Raise and support the vehicle. For additional information, refer to Section  100-02 Jacking and Lifting.

  1. Disconnect the power steering line from the power steering gear.
    1. Remove the bolt.
    1. Rotate the clamp plate.
    1. Detach the lines from the front axle crossmember.
    • Allow the fluid to drain into a suitable container.
  1. Remove the power steering pump to steering gear pressure line.

Installation
  1. Install a new power steering line to power steering pump union.

  1. CAUTION:
    CAUTION:Make sure the power steering line is correctly located in the valve body.
    Connect the power steering line to the power steering gear.
    1. Rotate the clamp plate.
    1. Install the bolt.
    1. Attach the lines to the front axle crossmember.
  1. Lower the vehicle.

  1. Connect the power steering line to the power steering pump.
    1. Connect the union.
    1. Install the bolt.

  1. Loosely install the accessory drive belt shield and attach the fuel charging wiring harness.

  1. Install the accessory drive belt shield retaining bolts.

  1. Close the bolt cover.
  1. Fill and bleed the power steering system. For additional information, refer to Section  211-00 Steering System - General Information.

Power Steering Pump to Steering Gear Pressure Line - 2.4L Duratorq-TDCi (Puma) Diesel-3.2L Duratorq-TDCi (Puma) Diesel > < Power Steering Pump - 2.3L Duratec-HE (MI4)