Suburban 3/4 Ton 4WD V8-305 5.0L (1986)
1.
Battery ground cable from the battery..
2.
Two reservoir retaining screws.
3.
Reservoir.
4.
Electrical connector at the motor.
5.
Fluid tube at the motor.
6.
Motor from the reservoir.
Install or Connect
1.
Motor to the reservoir.
2.
Fluid tube at the motor.
3.
Electrical connector at the motor.
4.
Reservoir.
5.
Two reservoir retaining screws.
6.
Battery ground cable to the battery.
PARTS INFORMATION
Shields required to complete this campaign will be mailed to the owners of record and to involved dealers by GMC Truck. Additional campaign
Shields can be obtained by contacting your Zone Office. Do not order shields from WDDGM. To complete vehicles in your inventory, and if an owner
requests installation of the shield, the 20 cents amount identified in the "Parts Allowance" column below represents 30% of dealer net for parts that were
furnished by GMC Truck. This amount is to be placed in the Net Item Amount column of the claim and use type Code "M".
Part
Parts
Quantity
Number
Description
Allowance
Per Vehicle
22063244
Deflector Shield
$.20
1
Windshield washer pumps are to be obtained from the Warehousing and Distribution Division of General Motors (WDDGM). To ensure that these parts
will be obtained as soon as possible, they should be ordered from WDDGM on a C.I.O. order with no special instruction code, but order on an advise
code (2).
Part
Quantity
Number
Description
Per Vehicle
22054183
W/S Washer Pump
1
WARRANTY INFORMATION Dealers should submit an accurately filled out Warranty Repair Order on each vehicle completed under this campaign.
Labor
Operation
Time
Trouble
Number
Description
Allowance
Code
V3340
Install Shield
0.2 hr.*
96
T7235
Replace W/S
0.3 hr.
96
Washer Pump
*For dealer to receive Administration Time Allowance associated with this Campaign, add 0.1 hour to the V3340 Labor Operation Time Allowance.
CAMPAIGN IDENTIFICATION LABEL
Each vehicle modified in accordance with the instructions outlined in this product campaign bulletin will require a "Campaign Identification Label".
Each label provides a space to include the five (5) digit Dealer Code of the dealer performing the campaign service. This information may be inserted
with a typewriter or ballpoint pen. Each "Campaign Identification Label" is to be located on the radiator core support in an area which wiU be visible
when the vehicle is brought in for periodic servicing by the owner. Apply "Campaign Identification Label" only on a clean dry surface.
ADMINISTRATIVE PROCEDURE
Procedures covering this campaign are outlined in Section V of your dealership's "GMC Truck Claims Processing Manual" #SD8519.
Truck & Bus Group
GMC Truck & Coach Operation General Motors Corporation 31 Judson Street Pontiac, Michigan 48058
Dear GMC Truck Owner:
